Cementless total hip replacement: Bio-active glass ceramic coating studied in dogs

We studied 2 types of a cementless total hip prosthesis in dogs. Both were coated with titanium plasma-spray. In both components, the pores in the deep layer of 1 group were further coated with apatite and wollastonite containing glass-ceramic (AW glass-ceramic). 50 dogs underwent unilateral total hip replacements, and were killed at 1, 3, or 6 months postoperatively. We evaluated the femoral and the acetabular components mechanically and histologically. At 1 month, the detaching load and bone ingrowth of the AW glass-ceramic-coated femoral and acetabular components were higher than those of the control implants. At 3 and 6 months there were no differences between the 2 types of components. Thus, AW glass-ceramic enhanced the early phase of cementless implant fixation.     

Hydroxyapatite coating enhances fixation of porous coated implants. A comparison in dogs between press fit and noninterference fit

Intimate contact at the bone-porous surface interface is not always achievable in noncemented prosthetic implantation. We investigated the effect of hydroxyapatite (HA) coating on skeletal attachment in noninterference fit 4 weeks after implantation in 6 mature dogs. The push-out test of HA-coated implants surrounded by a 1-mm gap showed a twofold increased shear strength and fivefold increased shear stiffness compared with titanium alloy (Ti) coated implants. The fixation of Ti implants was reduced by two thirds when inserted in a gap as compared with press fit, whereas HA-coated implants in gap showed anchorage close to implants in press fit. Only minor differences were found between HA and Ti implants in press fit. Histomorphometric analysis showed a significant increase in bone in direct contact to HA-coated implant as compared with Ti implants inserted both in gap and press fit. The study indicates that tightness of surgical fit is an important factor for sufficient fixation of the implant. However, our results demonstrate that hydroxyapatite coating almost eliminates the negative influence of noninterference fit between bone and unloaded implant.     

Hydroxyapatite coating improves fixation of pedicle screws. A clinical study

We investigated the effects of hydroxyapatite (HA) coating on the purchase of pedicle screws. A total of 23 consecutive patients undergoing lumbar fusion was randomly assigned to one of three treatment groups. The first received uncoated stainless-steel screws, the second screws which were partly coated with HA, and the third screws which were fully coated. The insertion torque was recorded. After 11 to 16 months, 21 screws had been extracted. The extraction torque was recorded. Radiographs were taken to assess fusion and to detect loosening of the screws. At removal, the extraction torques exceeded the upper limit of the torque wrench (600 Ncm) for many HA-coated screws. The calculated mean extraction torque was 29 +/- 36 Ncm for the uncoated group, 447 +/- 114 Ncm for the partly-coated group and 574 +/- 52 Ncm for the fully-coated group. There were significant differences between all three groups (p < 0.001). There were more radiolucent zones surrounding the uncoated screws than the HA-coated screws (p < 0.001). HA coating of pedicle screws resulted in improved fixation with reduced risk of loosening of the screws.     

Hydroxyapatite coating enhances fixation of porous coated implants: A comparison in dogs between press fit and noninterference fit

Intimate contact at the bone-porous surface interface is not always achievable in noncemented prosthetic implantation. We investigated the effect of hydroxyapatite (HA) coating on skeletal attachment in non-interference fit 4 weeks after implantation in 6 mature dogs. The push-out test of HA-coated implants surrounded by a 1-mm gap showed a twofold increased shear strength and fivefold increased shear stiffness compared with titanium alloy (Ti) coated implants. The fixation of Ti implants was reduced by two thirds when inserted in a gap as compared with press fit, whereas HA-coated implants in gap showed anchorage close to implants in press fit. Only minor differences were found between HA and Ti implants in press fit. Histomorphometric analysis showed a significant increase in bone in direct contact to HA-coated implant as compared with Ti implants inserted both in gap and press fit. The study indicates that tightness of surgical fit is an important factor for sufficient fixation of the implant. However, our results demonstrate that hydroxyapatite coating almost eliminates the negative influence of noninterference fit between bone and unloaded implant.     

Hydroxyapatite coating of hip prostheses. Effect on migration into the femur.

We studied two groups of femoral hip prostheses: 43 TiAlV ridged press-fit stems, and 26 with similar stems coated with hydroxyapatite on the proximal half. At one year, radiological measurement showed a mean downward migration of 0.99 mm for the TialV prostheses and 0.12 mm for the HA-coated prostheses (p = 0.0002). Hydroxyapatite coating appeared to provide effective bio-active supplementary fixation.     

Gap healing enhanced by hydroxyapatite coating in dogs.

During prosthetic implantation, gaps between the implant surface and the surrounding bone may occur resulting in reduced implant stability. In these instances bone-conductive materials might augment the formation of hosting bone into the pores of the implant and insure earlier implant stabilization and fixation by bony ingrowth. Titanium-alloy cylinders with a porous-titanium-alloy plasma spray coating were implanted into the medial femoral condyles in six mature dogs. In another group of six dogs, matched in age, weight, and gender, hydroxyapatite (HA) coated implants were used. All implants were surrounded by a 1-mm gap. Unilateral osteopenia of the knee, with a 20% reduction of bone density as judged by computed tomography scanning, was induced by 12 weekly intraarticular injections of carrageenin into the right knee before surgery. Four weeks after implantation, the HA-coated implants were compared to the parent porous-titanium implants by mechanical testing and histomorphometry. A marked positive influence of HA coating on bone mineralization and the strength of the interfacial bone between the bone and implant was found. The increment in interface shear strength and shear stiffness was three- to fivefold in osteopenic bone and two-fold in control bone. Coating of an unloaded porous-titanium-coated implant with HA accelerates the rate of bone ingrowth and thereby provides relatively high, early interfacial shear strengths in the presence of an initial gap between bone and implant even in the presence of osteopenic host bone.     

Hydroxyapatite (HA) coating appears to be of benefit for implant durability of tibial components in primary total knee arthroplasty

Background

It is unclear whether there is a clinical benefit to adding hydroxyapatite (HA) coatings to total knee implants, especially with the tibial component, where failure of the implant more often occurs. A systematic review of the literature was undertaken to identify all prospective randomized trials for determining whether the overall clinical results (as a function of durability, function, and adverse events) favored HA-coated tibial components.

Methods

A comprehensive literature search was performed for the years 1990 to September 16, 2010. We restricted our search to randomized controlled trials involving participants receiving either an HA-coated tibia or other forms of tibial fixation. The primary outcome measures evaluated were durability, function, and acute adverse events.

Results

Data from 926 evaluable primary total knee implants in 14 studies were analyzed. Using an RSA definition for durability, HA-coated tibial components (porous or press-fit) without screw fixation were less likely to be unstable at 2 years than porous and cemented metal-backed tibial components (RR = 0.58, 95% CI: 0.34–0.98; p = 0.04, I² = 39%, M-H random effects model). There was no significant difference in durability, as measured from revision and evaluated at 2 and 8–10 years, between groups. Also, functional status using different validated measures showed no significant difference at 2 and 5 years, no matter what measure was used. Lastly, there was no significant difference in adverse events. Limitations included small numbers of evaluable patients (≤ 50) in 7 of the 14 trials identified, and a lack of “hard” evidence of durability with need for replacement (i.e. frank failure, pain, or loss of functionality).

Interpretation

In patients > 65 years of age, an HA-coated tibial implant may provide better durability than other forms of tibial fixation. Larger trials should be undertaken comparing the long-term durability, function, and adverse events of HA-coated implants with those of other porous-coated tibial implants in younger, more active OA patients.     

Hydroxyapatite (HA) coating appears to be of benefit for implant durability of tibial components in primary total knee arthroplasty

Background It is unclear whether there is a clinical benefit to adding hydroxyapatite (HA) coatings to total knee implants, especially with the tibial component, where failure of the implant more often occurs. A systematic review of the literature was undertaken to identify all prospective randomized trials for determining whether the overall clinical results (as a function of durability, function, and adverse events) favored HA-coated tibial components.

Methods A comprehensive literature search was performed for the years 1990 to September 16, 2010. We restricted our search to randomized controlled trials involving participants receiving either an HA-coated tibia or other forms of tibial fixation. The primary outcome measures evaluated were durability, function, and acute adverse events.

Results Data from 926 evaluable primary total knee implants in 14 studies were analyzed. Using an RSA definition for durability, HA-coated tibial components (porous or press-fit) without screw fixation were less likely to be unstable at 2 years than porous and cemented metal-backed tibial components (RR = 0.58, 95% CI: 0.34–0.98; p = 0.04, I² = 39%, M-H random effects model). There was no significant difference in durability, as measured from revision and evaluated at 2 and 8–10 years, between groups. Also, functional status using different validated measures showed no significant difference at 2 and 5 years, no matter what measure was used. Lastly, there was no significant difference in adverse events. Limitations included small numbers of evaluable patients (≤ 50) in 7 of the 14 trials identified, and a lack of “hard” evidence of durability with need for replacement (i.e. frank failure, pain, or loss of functionality).

Interpretation In patients > 65 years of age, an HA-coated tibial implant may provide better durability than other forms of tibial fixation. Larger trials should be undertaken comparing the long-term durability, function, and adverse events of HA-coated implants with those of other porous-coated tibial implants in younger, more active OA patients.     

Pedicled scapular apophysis transplantation. Growing grafts studied in dogs

Twenty-eight immature dogs, divided into three groups, have been studied to determine the possibilities of pedicled epiphyseal transplantation from a rarely used donor site area, the scapula. One group of 8 immature dogs were studied anatomically using India ink and Batson's compound injection methods. We identified the vascular pattern of the diaphyseal portion of the graft, consisting of the lateral crest or border of the scapula. In two groups of 10 immature dogs, this area was used as a pedicled island graft to rebuild the semiresected or totally resected proximal humerus. There were marked differences between these two groups on the basis of morphologic, histologic, histochemical and electron microscopic aspects of the samples. Preservation of normal growth appeared to be directly related to the compressive forces applied to the graft. Preservation of the cartilage was also related to the biomechanical situation; fibrocartilage and signs of arthrosis were noted 1 year after the operation in several animals whose humeri had been fully subjected to normal stresses. Both the diaphyseal and epiphyseal areas had increased one- to fivefold in volume, but longitudinal growth was markedly deficient.     

Hydroxyapatite orbital implant covered with fascia lata in post-enucleation eye reconstruction

The loss of an eye is a highly traumatic event, with severe psychological and physical implications. From November 1996 to June 2002, 32 patients underwent eye enucleation and placement of a hydroxyapatite orbital implant wrapped in autologous fascia lata; this was then fixed to the four rectus muscles. Motility was noted in all reconstructed sockets, without implant related complications. The immediate post-operative period was uncomplicated and all patients were discharged within 48 to 72 h after surgery. The orbital implant remained well positioned without dehiscence and motility was satisfactory. The follow-up ranged from 8 months to more than 5 years.Presented at the 14th Annual Meeting of the European Association of Plastic Surgeons (EURAPS), Vienna, Austria, 29–31 May 2003     

Epidural anesthesia modifies cardiovascular responses to severe hypoxia in dogs

Hypoxia is a critical and sometimes fatal complication of anesthesia. Since there is little information on the cardiovascular response to hypoxia during epidural anesthesia, we assessed the effects of epidural anesthesia on the cardiovascular response to hypoxia and on survival in dogs.
We randomly assigned 36 mongrel dogs to one of three groups according to the anesthede technique used: the thoracic group (n=12) received thoracic epidural anesthesia plus general anesthesia, the thoracolumbar group (n=12) received thoracolumbar epidural anesthesia plus general anesthesia, and the control group (n=12) received general anesthesia alone. We monitored hemodynamics and plasma catecholamine concentrations and assessed survival in these groups during normocapnic hypoxia (FiO₂, 0.09 for 120 min).
During hypoxic challenge, PaCO₂ and PaO₂ values were similar in all groups. In both groups that received epidural anesthesia, heart rate, systolic and diastolic arterial pressures, and plasma epinephrine and norepine-phrine concentrations were lower and arterial pH was greater than in the control group. There was no significant difference in survival among groups.
Epidural anesthesia modified both the physiologic cardiovascular and catecholamine responses to hypoxia. Epidural anesthesia of the thoracic region did not appear to accelerate cardiac arrest, but it attenuated the development of metabolic acidosis during hypoxia.     

Quantification of implant micromotion, strain shielding, and bone resorption with porous-coated anatomic medullary locking femoral prostheses.

Fourteen femora containing porous-coated anatomic medullary locking (AML) femoral prostheses were retrieved from 12 patients at autopsy. Clinical roentgenograms in 13 femora showed bone remodeling changes, indicating that the implants were fixed by osseointegration. Under simulated physiologic loading, micromotion between the implant and the bone was measured using electrical displacement transducers connected to the implant and to the adjacent cortex. The micromotion between the implants at the areas of porous coating and the adjacent cortex in the one case of failed bone ingrowth measured 150 microns. Maximum relative motion between the cortex and the implant in the areas of porous coating for the 13 cases showing signs of bone ingrowth was 40 microns, and this was completely elastic relative displacement. With all implants, the micromotion between the cortex and the stem was always greatest over the uncoated portion of the stem. Four of the implants were proximally porous coated. With these, the micromotion was greater over the uncoated areas than with more extensively coated stems and was always greatest at the uncoated tip of the prosthesis. The amount of micromotion was directly related to the extent of porous coating on the implant. Maximum tip motion for the proximally coated implants was 210 micra, whereas for the fully porous-coated implants, it was 40 microns. In nine of the autopsies, the contralateral normal femur was obtained in addition to the femur containing the AML (the in vivo remodeled femur). These were used for comparative studies of strain shielding and femoral remodeling. Cortical strains were measured in the in vivo remodeled femora and were compared with measurements made in the contralateral normal femora before and following implantation of a stem identical to that present on the clinically treated side. The data showed major strain reductions in all the postmortem implanted normal femora. Comparison of the strain data from the postmortem implanted normal femora with those from the in vivo remodeled femora clearly indicated that extensive bone remodeling did not result in restoration of cortical strain levels anywhere near normal. Strain shielding continued to exist in all of the remodeled specimens, even up to 7.5 years after surgery. This strain shielding was associated with bone remodeling changes that resulted in regional reductions in bone mineral content that ranged from 7% to 78%. These observations are unique, important, and valuable in defining the in vivo function and clinical behavior of this type of porous-coated femoral component.     

Acetabular micromotion as a measure of initial implant stability in primary hip arthroplasty. An in vitro comparison of different methods of initial acetabular component fixation.

Micromotion has been shown to affect bony ingrowth into cementless components. This study was designed both to quantitate initial micromotion at the prosthesis-periacetabular bony interface and to compare different methods of commonly employed acetabular component fixations, ie, a press-fit hemispherical titanium cup, a press-fit hemispherical titanium cup with one and two dome screws, a press-fit titanium hemispherical cup with three spikes, and a cemented chromium-cobalt cup. The press-fit component without screws demonstrated the greatest motion equaling 162 microns at the ilium, 97 microns at the publis, and 54 microns at the ischium. With one and two screws placed into the dome, the mean ileal displacement decreased by 28 microns (17%) and 36 microns (22%), respectively. Dome screw placement demonstrated a minimal effect at the pubis and ischium. Compared to the press-fit component without augmentation, the tri-spike motion was less at the pubis and ischium. The cemented prosthesis provided the least amount of motion in all three areas tested. This experiment demonstrates that the ilium provides the least amount of support to immediate acetabular fixation, while the pubis (anterior column) and ischium (posterior column) provide more stability. One dome screw does not affect the stability of a hemispherical prosthetic cup significantly. A two dome screw fixation provides an added method of support at the ilium, but fails to decrease motion at the pubis or ischium significantly. The tri-spike fixation does not restrict motion at the ilium to the extent as the dome screws, but its effect at the ischium and pubis is much more pronounced. The obvious difference between initial motion seen with cemented versus uncemented components may suggest that before surgery, patients may need a period of protected weight bearing until ingrowth has occurred.     

Control of interfragmentary micromotion in Ilizarov distractional osteogenesis.

Growth of the regenerate is affected by various factors during the course of Ilizarov distractional osteogenesis. One of the chief biomechanical factors that influences the quality and rate of bone formation is fixator stiffness. A four-ring Ilizarov apparatus was configured around a synthetic tibia. In a series of trials involving a uniform axial load, different transfixing wire tensions, and the separation of paired proximal and distal rings, fragment displacement was measured. Preliminary results suggest that the effect produced by the distraction of ring pairs on interfragmentary micromotion is as significant as pretensioning of the wires.     

Heparinized materials for control of the formation of the laminectomy membrane in experimental laminectomies in dogs

This study examined the efficacy of heparinized biodegradable materials in the prevention of post-laminectomy scar formation using a canine system. Six-level noncontiguous laminectomies were performed on five adult canines. Exposed dura at each level was covered with the following: (1) nothing (control); (2) fat; (3) fat and autogeneic bone; (4) heparinized Avitene; (5) heparinized Surgicel; or (6) heparinized collagen gel. Canines were killed 16 weeks postoperatively and histologic specimens examined. Fibrous adhesions were abundant at Site 1 (control). Free fat grafts were well preserved and did not permit adhesions at Sites 2 and 3. None of the heparinized materials was as effective as fat in controlling scar formation. Overlying bone at Site 3 did not alter the quality of a free fat graft placed over the dura, a point possibly significant for laminectomies followed by fusion.     

Intermittent micromotion inhibits bone ingrowth. Titanium implants in rabbits.

We studied the effects of micromotion on bone ingrowth into a 1-mm canal through a titanium chamber implanted in the proximal tibia of rabbits. The implant surface became "osseointegrated," but an interior core was movable, allowing the central portion of the canal to be moved in relation to the ends. Thus, the ingrowing bone in the canal had to pass an area of ad latus motion. When implanted in rabbit tibiae, the canal became filled with ingrown cancellous bone. Bone ingrowth was inhibited by 20 cycles of 0.5-mm movement applied during a 30-second period once daily. With this regimen, the canal was usually filled with vascularized fibrous tissue and significantly less bone. The micromotion chamber may enable detailed studies of the effects of different motion variables on ingrowth of bone.     

Hydroxyapatite coating enhances polyethylene terephthalate artificial ligament graft osseointegration in the bone tunnel

The purpose of this study was to investigate whether hydroxyapatite (HAp) coating could induce polyethylene terephthalate (PET) artificial ligament graft osseointegration in the bone tunnel. Twenty-four New Zealand white rabbits underwent artificial ligament graft transplantation in bilateral proximal tibia tunnels. One limb was implanted with HAp-coated PET graft, and the contralateral limb was implanted with non-HAp-coated PET graft as control. The rabbits were randomly sacrificed at four and eight weeks after surgery. The loads to failure of the experimental group at eight weeks were significantly higher than those of the control group (p = 0.0057). Histologically, application of HAp coating induced new bone formation between graft and bone at eight weeks compared with the controls. Real-time polymerase chain reaction examination revealed significantly elevated messenger ribonucleic acid expression levels of osteopontin and collagen I in the grafts of the HAp group compared with the controls at four weeks (p < 0.05). The study has shown that HAp coating on the PET artificial ligament surface has a positive effect in the induction of artificial ligament osseointegration within the bone tunnel.     

Prophylaxis of the laminectomy membrane. An experimental study in dogs.

Sixty laminectomies were performed in dogs to investigate the prevention of the laminectomy membrane and its side effects. These operations were distributed in six groups of 10, one was a control group, and in the others the bone defect was protected with different materials (Oxicel, Silastic, Dacron, methyl methacrylate, and Kiel bone graft). After a survival of 2 months, suboccipital myelography was performed, immediately after which the animals were sacrificed and the operated spinal slice obtained. The different radiographic densities of the tissues of each slice were calculated and the diverse histological nature identified by hematoxylin and eosin, periodic acid Schiff, Masson's trichrome, and Gomori's reticulin strains. Only the acrylic plastic and the Kiel bone graft prevented expansion of the scar tissue inside the spinal canal and adhesions between the dura and the cicatrical overlying muscles. Therefore, the authors suggest that a solid barrier is necessary to effectively prevent the so-called "laminectomy membrane."