Respiratory disease in a textile factory in Nicaragua

This is the first epidemiologic study conducted in a textile mill in Nicaragua using techniques and diagnostic criteria similar to those used in the United States and England. The prevalence of byssinosis and nonspecific respiratory symptoms were studied in 194 workers in a cotton mill in Managua. Limited environmental sampling, performed using a vertical elutriator in yarn preparation and weaving areas, indicated that exposures were similar to those reported in other parts of the developing world. A modified translated version of the Medical Research Council respiratory questionnaire was administered. Pulmonary function tests were performed before and after the Monday workshift to measure across-shift change in ventilatory function. The prevalence of byssinosis was 5.9% and all the cases occurred among exposed women. Nonspecific respiratory symptoms were also more prevalent among exposed workers. After adjusting for age, gender, smoking habit, and work tenure, the exposure odds ratios for usual cough and usual phlegm were 3.3 and 2.2, respectively. The association between exposure and across-shift decrement in FEV1 was not significant. Byssinotic workers, however, had greater decrements in FEV1% than those without byssinosis: 5.5% versus 1.8%. A consistent gender effect was observed in which both exposed and unexposed women were found to have greater across-shift decrements in FEV1 than men. The gender difference existed among long-term workers as well as workers who had been employed less than 2 years. Results are related to cotton dust exposure, as has been documented elsewhere. The poorer health status of the women in this study population deserves follow-up.     

Lung function,airway reactivity,and atopy in newly hired female cotton textile workers

To assess changes in lung function and airway reactivity resulting from exposure to cotton dust, and the role of atopic status in these changes, the authors observed a group of 225 newly hired Chinese textile workers for 1 yr. All workers were female, lifelong nonsmokers, and none of them had been exposed previously to cotton or other occupational dust. Atopic status was determined at baseline. Spirometry, response to methacholine challenge, and total serum immunoglobulin E level were examined at baseline and again after subjects began work in the cotton mills. Obvious cross-shift drops in forced expiratory volume in 1 sec (FEV1.0), and declines in forced vital capacity and FEV1.0 over 1 yr, were observed. Atopic workers had a significantly greater acute drop in FEV1.0 than did nonatopic workers. Both atopic and nonatopic workers had slightly increased airway reactivity at 1 yr, compared with baseline values. The results suggest that exposure to cotton dust is responsible for acute and longitudinal declines in lung function, as well as for slightly increased airway reactivity. Atopy may interact with cotton dust to accentuate the acute lung function response.     

Is chronic airway obstruction from cotton dust exposure reversible?

BACKGROUND: Exposure to cotton dust is known to cause chronic airway obstruction, but there is little information on whether the obstructive impairment is reversible after the exposure stops. METHODS: Longitudinal changes in lung function were evaluated among 429 cotton textile workers and 449 silk workers in Shanghai, China, beginning in 1981. Both active and retired workers were tested every 4 to 6 years for 15 years. RESULTS: Overall, cotton workers had greater annual declines in forced expiratory volume in 1 second (FEV1) and forced vital capacity (FVC). Compared with active workers, retired cotton workers had lower annual loss of FEV1, although the retired workers had a greater loss during their active employment than the currently active workers. No such trends were detected in silk workers. Annual declines in FEV1 in retired cotton workers were smaller with increasing time since retirement. Multivariate analysis showed that retirement was a substantial contributing factor for improved FEV1 and FVC in the cotton workers, especially among those who did not smoke. Correspondingly, remission of airflow obstruction, defined as a ratio of FEV1 and FVC of less than 70%, was more common in retirees than in the active workers, and more common in nonsmokers than in smokers. CONCLUSION: Chronic airway obstruction related to long-term exposure to cotton dust may be partially reversible after the exposure ceases, although lung function does not return to the level found in unexposed workers.     

Cotton dust and endotoxin exposure and long-term decline in lung function: results of a longitudinal study

BACKGROUND: To evaluate the relationship between long-term exposure to cotton dust and Gram-negative bacterial endotoxin on lung function, we conducted an 11-year follow-up study of cotton textile workers in Shanghai, China. METHODS: Workers at a nearby silk-thread manufacturing mill were used as a referent population. Ninety percent of the original cohort of 445 cotton and 467 silk textile workers--both active and retired--were identified for testing in the 11th year. Questionnaires and spirometric testing were performed, as well as cotton dust and endotoxin sampling at three points over the 11-year follow-up period: at baseline, at Year 5, and at Year 11. After excluding deaths and subjects on sick-leave, 84% of the original cohort had complete health and environmental data. RESULTS: The data were reanalyzed using generalized estimating equations feedback model which allow for subject transfer over time between work areas, various exposure levels to dust and endotoxin, and FEV1. Cotton workers had a larger loss of FEV1 during the first 5 years of study (-40 mls/yr) as compared with the second 6 years of follow-up (-18 mls/yr). During the same periods, the average decline among silk workers was slightly higher in the first period, but was more consistent (-30 mls/yr vs. -27 mls/yr), and these differences could not be explained by worker selection or dropout. When cumulative exposure to dust and endotoxin were estimated and used in a multivariate model (GEE) for FEV1 loss, cumulative dust, but not endotoxin, was associated with 11-year loss in FEV1 after adjustments for confounders. There was evidence of feedback between dust-exposure levels and FEV1, indicating the existence of a healthy-worker survivor effect. After accounting for a healthy-worker survivor effect, we found a significant relationship between dust exposure and FEV1 decline. CONCLUSIONS: Our results suggest that cotton dust is more strongly associated with chronic airflow limitation than associated endotoxins. Further work is needed to clarify potential reversibility after cessation of exposure, and the relative contributions of dust, endotoxin, and tobacco to chronic respiratory impairment in cotton and other vegetable-exposed workers.     

Across-shift lung function variation in cottonseed oil workers

BACKGROUND: The effects of cotton dust on pulmonary function among workers employed in cotton-spinning mills are well known. However, little data exist on the prevalence of this disorder in 'non-textile' cotton industries, including cottonseed oil mills, where high levels of exposure to dust have been demonstrated. AIMS: This study was performed in order to determine the across-shift and across-week decline of FEV(1) and respiratory symptoms among workers in a cottonseed oil mill. METHODS: Sixty-six exposed and 48 unexposed workers of a cottonseed oil mill in Turkey were investigated by questionnaire and lung function test (LFT). LFTs were performed before and after shift on all the working days of the week. Acute airway response was defined as an across-shift decline in FEV(1) of 5% or more on the first working day. RESULTS: Smoking was the only risk factor for having respiratory symptoms. Acute airway response was more frequently observed in the exposed group as compared to the unexposed group (OR = 6.2, 95% CI = 2.3-16.7). The median across-shift decline in FEV(1) on the first day (120 ml) significantly improved on the following days (10, 50, 60 and -30 ml). CONCLUSION: Smoking appears to be the main risk factor for having respiratory symptoms. Cottonseed dust may cause an acute pulmonary function decline on the first working day, but not on the following days of the week. This decline is associated with respiratory symptoms in exposed workers.     

Respiratory problems among cotton textile mill workers in Ethiopia.

This study was conducted to investigate the prevalence of respiratory problems, in particular byssinosis, and to explore factors associated with their occurrence among a group of 595 randomly selected workers representing 40.5% of those exposed to dusty operations in a typical Ethiopian cotton textile mill. A standard questionnaire on respiration was administered and pre and postshift forced vital capacity (FVC) and forced expiratory volume in one second (FEV1) were determined for each worker; workers found to have byssinosis and other respiratory diseases were compared with workers having no respiratory diseases in terms of the level and duration of exposure to cotton dust and other variables. Multiple area air samples from different sections were analysed for elutriated cotton dust concentrations (0.86-3.52 mg/m3). The prevalence of byssinosis was 43.2% among blowers and 37.5% in carders in comparison with four to 24% among workers in other sections. Prevalence of chronic bronchitis ranged from 17.6 to 47.7% and bronchial asthma from 8.5 to 20.5% across all sections. Significant across shift decrements in FEV1 and FVC were seen in those workers with respiratory tract diseases compared with those workers without such diseases. A significant dose response relation for pulmonary function and respiratory illnesses was also found by regression analysis. Preventive measures are proposed. Further research including a nationwide survey of textile mills is suggested. This is the first epidemiological study of the textile industry in Ethiopia.     

Respiratory disease in cotton textile workers in the People's Republic of China. I. Respiratory symptoms

The prevalence of byssinosis and nonspecific respiratory symptoms was studied in 887 textile workers with at least two years of employment in two cotton mills and one silk mill in Shanghai, the People's Republic of China. A standardized respiratory questionnaire was used, and environmental sampling was performed with vertical elutriators and colorimeter grading. Eight percent of the cotton textile workers complained of byssinosis. The reports of byssinosis were mostly mild (grade 1/2), more prevalent among women, and unrelated to duration of employment or elutriator dust levels. Nonspecific respiratory symptoms were significantly more prevalent among cotton textile workers than silk workers. After adjustment for age, gender, and smoking in logistic regression models, the odds ratios for the effect of working in cotton textile mills on chronic bronchitis, chronic cough, and frequent chest illness were 3.3, 2.9 and 4.7, respectively. Although none of the symptoms were related to current dust levels, the range of exposures was narrow, and information was only available on current levels of cotton dust. This study represents the first respiratory survey of the textile industry in China using diagnostic criteria similar to that used in the United States and England; it defines a cohort for prospective investigation.     

Respiratory problems among cotton textile mill workers in Ethiopia

This study was conducted to investigate the prevalence of respiratory problems, in particular byssinosis, and to explore factors associated with their occurrence among a group of 595 randomly selected workers representing 40.5% of those exposed to dusty operations in a typical Ethiopian cotton textile mill. A standard questionnaire on respiration was administered and pre and postshift forced vital capacity (FVC) and forced expiratory volume in one second (FEV1) were determined for each worker; workers found to have byssinosis and other respiratory diseases were compared with workers having no respiratory diseases in terms of the level and duration of exposure to cotton dust and other variables. Multiple area air samples from different sections were analysed for elutriated cotton dust concentrations (0.86-3.52 mg/m3). The prevalence of byssinosis was 43.2% among blowers and 37.5% in carders in comparison with four to 24% among workers in other sections. Prevalence of chronic bronchitis ranged from 17.6 to 47.7% and bronchial asthma from 8.5 to 20.5% across all sections. Significant across shift decrements in FEV1 and FVC were seen in those workers with respiratory tract diseases compared with those workers without such diseases. A significant dose response relation for pulmonary function and respiratory illnesses was also found by regression analysis. Preventive measures are proposed. Further research including a nationwide survey of textile mills is suggested. This is the first epidemiological study of the textile industry in Ethiopia.     

Byssinosis in Guangzhou, China.

OBJECTIVES--To study the prevalence of byssinosis and other respiratory abnormalities in workers exposed to cotton dust in Guangzhou in two factories that processed purely cotton. METHODS--All the 1320 workers exposed were included. The controls were 1306 workers with no history of occupational dust exposure. Total dust and inhalable dust were measured by Chinese total dust sampler and American vertical elutriator respectively. A World Health Organisation questionnaire was used. Forced vital capacity (FVC) and forced expiratory volume in one second (FEV1) were measured by a Vitalograph spirometer. RESULTS--The median inhalable dust concentrations ranged from 0.41 to 1.51 mg/m3 and median total dust concentrations from 3.04 to 12.32 mg/m3. The prevalence of respiratory abnormalities in the cotton workers were (a) typical Monday symptoms 9.0%; (b) FEV1 fall by > or = 5% after a shift 16.8%; (c) FEV1 fall by > or = 10% after a shift 4.2%; (d) FEV1 < 80% predicted 6.1%; (e) FEV1/FVC < 75% 4.0%; (f) cough or phlegm 18.2%; (g) chronic bronchitis 10.9%; and (h) byssinosis, defined by (a) plus (b) 1.7%. With the exception of (d), most of the prevalences increased with increasing age, duration of exposure, and cumulative inhalable dust exposure. No increasing trends of respiratory abnormalities were found for current total dust, inhalable dust, and cumulative total dust concentrations. Compared with controls, after adjustment for sex and smoking, with the exception of (d), all the pooled relative risks of respiratory abnormalities were raised for cotton exposure. CONCLUSION--It is concluded that cumulative inhalable cotton is likely to be the cause of byssinotic symptoms, acute lung function decrements, cough, or phlegm, and chronic bronchitis.     

The study of byssinosis in China: a comprehensive report

Cross-sectional studies were conducted during 1981-1983 among 861 textile workers in 3 cotton mills and 822 controls in 2 silk factories. Questionnaire and lung function tests were taken and inhalable dust concentrations were measured. Prevalence of byssinosis was 5.6%. Average dust concentrations were highest in carding rooms, 1.47-1.99 mg/m3. The correlations (r) between prevalence of byssinosis and dust concentrations was 0.64 (p less than 0.05). The prevalence of chronic bronchitis was 14.4% in cotton workers and 5.1% in controls (p less than 0.05). Acute FEV1 percent decrement (greater than 5%) was higher among cotton workers (32.1%) compared to controls (14.5%) (p less than 0.001). In one cotton blanket factory, the prevalence of byssinosis and chronic bronchitis was higher among workers in the high-dust work areas. Long-term effect studies included pulmonary function test among 173 cotton workers and 373 controls, retired 1-10 years, using the flow volume curve (FVC); chest X-rays of 140 pairs of cotton workers and controls with working tenures over 20 years; and examination of lobectomy specimens of 8 textile workers matched with 16 controls. In male cotton workers, only smokers had a prominent decrement of lung function indices, except FVC. For non-smoking females, there was no difference between the two groups. Additive effects were seen between smoking and dust exposure. According to the International Labor Organization (ILO) Pneumoconiosis Classification, the prevalence of abnormality (profusion greater than 1/0) was 4.3% and 8.7% in non-smoking controls and cotton workers. The interstitial changes on X-ray due to smoking would be much heavier. Additive effects also existed between smoking and dust exposures. No significant changes attributable to dust exposure were seen on pathological section of lobectomy specimens.     

A comparative environmental and medical study of dust exposure in jute and cotton mills in Burma

Jute is extensively cultivated and processed in Burma, as well as "lower-grade" cotton. This study was conducted there to compare dust exposure in jute and cotton mills, to study the acute and chronic effects of dust exposure on workers, and to establish exposure-response relationship. A sample of 799 male and female workers in two jute mills and two cotton textile mills, as well as a control group of 153 matching subjects, was examined, and dust exposure in the work environment was evaluated. Very high dust concentrations existed in the early stages of jute processing and sorting, which were reduced when jute fibers got cleaner, as in drawing and spinning, and were related to the grade of the processed fiber. Much lower concentrations of dust existed in the cotton mills, but exceeded the TLV (ACGIH) only in opening and cleaning and in carding operations. However, byssinosis occurred only in workers exposed to cotton dust, particularly among males, and its prevalence was related to the level and duration of dust exposure. Chronic bronchitis, cough and wheezing occurred at higher rates among all workers than in the control, while irritation to nose and throat, eyes and skin prevailed only among jute workers. A significant reduction in FVC, FEV1.0 and PEF (before and during shift) was observed in workers compared to control subjects, and was related to workers' exposure and age; however, this reduction was not related to symptoms of different respiratory conditions. "Cheroots" smoking was found to be an important potentiating factor in the occurrence of non-specific respiratory diseases and reduction in FEV1.0, particularly among jute workers.     

Respiratory disability in ex-cotton workers.

A high proportion of textile workers handling cotton and flax complain of respiratory symptoms and show a loss in lung function. These effects are reversible in the early stages but the degree to which they lead to permanent respiratory disability is unknown. Two surveys were therefore conducted in which respiratory function and symptoms were compared in ex-textile workers and in control subjects who had never been exposed to textile dusts. One survey was of ex-flax workers in Northern Ireland. The present survey was of ex-cotton workers in Lancashire. A survey of random population samples in Oldham and Bolton, in both of which cotton had formerly been the most important source of employment, was conducted. After allowing for age, height, and smoking, lung function was about 2-8% lower in the ex-textile workers than in controls who had never been exposed to any dust. Ex-textile workers were slightly shorter than the controls, suggestive of past social and nutritional deprivation which may have contributed to the decrement in lung function. There was evidence of a small but increasing decrement in lung function with an increase in a "dust exposure" score. For men, about 15 years of heavy dust exposure was associated with a loss in FEV1 equivalent to that shown by light or ex-smokers. For women, 15 years of heavy dust exposure appeared to be associated with a decrement in FEV1 about half that of light smoking.     

Beryllium exposure and pulmonary function: a cross sectional study of beryllium workers.

A cross sectional study of 297 white male workers employed in a large beryllium plant was conducted to test the hypothesis that long term exposure to beryllium is associated with decrements in pulmonary function. Spirometric measurement of pulmonary function, chest radiographs, and arterial blood gas measurements were collected. After controlling for age, height, and smoking in multivariate regression models, decrements in FVC and FEV1 were found to be associated with cumulative exposure to beryllium in the period up until 20 years before the health survey. These decrements were observed in workers who had no radiographic abnormalities. The alveolar-arterial oxygen difference was associated with cumulative exposure in the 10 years immediately before survey, after controlling for age and smoking. These findings suggest that beryllium may have both short and long term pulmonary effects that are distinct from the classic forms of acute and chronic beryllium disease.     

A longitudinal study of lung function in jute processing workers.

A 5-y follow-up study of pulmonary function was conducted in 1982 and in 1987 for 50 current and retired jute-processing workers who had been employed for more than 10 y in a jute mill in China. Control subjects, who had no history of dust or gas exposure, were selected from a paper-packing plant in the same city. Forced expiratory maneuvers were conducted in the same manner in both 1982 and 1987. The jute workers' pulmonary functions, i.e., forced vital capacity (FVC), forced expiratory volume in 1 s (FEV1.0), and forced expiratory flow (FEF25-75%), were more compromised than were pulmonary functions in the controls for the same 5-y period; however, only the increased incidence of abnormal FEV1.0s in jute workers was statistically significant. Male jute workers had significantly higher annual decrements of FVC, FEV1.0, and FEF25-75% than did control workers. Regression analysis indicated that in 1987, predicted values of FEV1.0 and FEF25-75% for the jute workers were related to years of employment. Our results suggest that long-term exposure to jute dust could produce chronic loss of lung function.     

Lung function in textile workers.

Acute changes in ventilatory function during a workshift with exposure to hemp, flax, and cotton dust were measured on Mondays in a group of 61 textile workers, all working on carding machines. In addition, single-breath diffusing capacity (DLCOSB) was measured before dust exposure on Monday in 30 of the 61 workers. Large acute reductions during dust exposure were recorded in maximum expiratory flow rate at 50% VC (MEF50%), ranging from 38 to 22%. Acute reductions of FEV1-0 were considerably smaller, ranging from 17 to 9%. There was a statistically significant increase in residual volume (RV) with very small and insignificant changes in total lung capacity (TLC). Although preshift FEV1-0 and FVC were decreased, DLCOSB was within normal limits. Plethysmographic measurements in six healthy volunteers exposed to hemp-dust extract confirmed the results obtained in textile workers, that is, that TLC does not change significantly during dust-induced airway constriction and that maximum expiratory flow rate at 50% VC (MEF50%) is a more sensitive test than FEV1-0 in detecting acute ventilatory changes caused by the dust extract.     

Follow-up study of respiratory health of newly-hired female cotton textile workers

BACKGROUND: Numerous studies have investigated adverse effects of exposure to cotton dust on respiratory health, but very limited longitudinal data are available with regard to the early pulmonary response to cotton dust. Moreover, the adverse effects of occupational exposure to cotton dust have been difficult to separate from the confounding effects of smoking. This setting provided a unique opportunity to evaluate early respiratory effects in newly hired and non-smoking female textile workers. METHODS: To identify early pulmonary responses to cotton dust exposure and associated gram-negative bacterial endotoxin, respiratory symptoms and pulmonary function in 225 newly-hired textile workers were assessed at work initiation, and at three and twelve months later. RESULTS: All the workers were females and nonsmokers, with an average age of 18 years. Symptom incidence at three months was 3.6% for usual cough with phlegm, and 6.7% for usual dry cough. Lung function changes were detectable at one year: FEV1 declined by 70 ml and FVC by 124 ml over the year, and workers reporting respiratory symptoms at three months showed a significantly greater cross-shift drop in FEV1 (- 2.3%) than those without the symptoms (- 0.7%). CONCLUSIONS: These results suggest that the occurrence of respiratory symptoms represents the earliest response to cotton dust exposure, followed by lung function changes. Early respiratory symptoms may be a risk factor for subsequent loss of pulmonary function in cotton textile workers.     

Acute respiratory effects of exposure to stainless steel and mild steel welding fumes

Over the past few years, many studies, including one on our previous work, have examined the chronic effects of fumes from stainless steel (SS) welding on the health of welders. These chronic effects have been related to concentrations of chromium and nickel in SS welding fumes. The present study examined the acute respiratory effects of welding fumes in the workplace by measuring the across-shift changes in a population of 144 SS and mild steel (MS) welders and 223 controls. Manual Metal Arc, Metal Inert Gas, and Tungsten Inert Gas welding processes were studied. Pulmonary function tests were performed at the start (ante, or A) and at the end (post, or P) of the work shift. The study of sensitization to harmful respiratory effects of welding was based on the study of the (P-A)/A ratio (%) of the spirometric variations during the shift. The means of these ratios in the control subjects were used to account for the circadian effect. In SS welders we observed a significant decrease in forced vital capacity (FVC) during the shift. Significant across-shift decrements in forced expiratory volume in 1 second (FEV1) and FVC were related to the SS welding exposure compared with MS welding. Moreover, the across-shift decreases in FEV1, FVC, and peak expiratory flow (PEF) were significantly related to the Manual Metal Arc welding process, compared with Metal Inert Gas techniques (respectively, PEF = -2.7% of baseline values [SD, 11.9] vs 2.0% of baseline values [SD, 7.7] P = 0.04; FVC = -1.5% of baseline values [SD, 4.8] vs 0.2% of baseline values [SD, 4.5] P = 0.05). We also demonstrated the influence of duration of SS welding exposure on the course of lung function during the work shift. After 20 years of SS welding activity, SS welders had more significant across-shift decreases than MS welders with a similar MS exposure duration (respectively, FEV1 = -2.7% of baseline values [SD, 5.9] vs 0.7% of baseline values [SD, 4.2] P = 0.008; PEF = -3.8% of baseline values [SD, 9.6] vs 2.3% of baseline values [SD, 6.5] P = 0.04). We concluded that welding-related lung function responses are seen in SS compared with MS welders and in those with a longer lifetime welding history.     

Interaction of atopy and exposure to cotton dust in the bronchoconstrictor response.

A survey of 255 workers in four cottonseed crushing mills included a respiratory health questionnaire, allergy skin testing, and measurements of lung function over the Monday working shift. Atopy was defined as having two or more positive weal reactions to common inhalant antigens. Categories of exposure to dust were based on the stage of milling, and one category contained workers with continuous exposure to cotton dust derived from linters, the cotton fibres adherent to cottonseed. Atopy and exposure to dust were found to have significant interaction: large mean declines in FEV1 and FEF 25-75 occurred only in the workers exposed to linter dust who were also atopic. Skin-testing surveys in cotton textile mills have concentrated on specific cotton antigen reactivity and its first-order relations to symptoms. Our results indicate a need to identify atopic workers, and to search for interactions between atopy and other variables that may influence acute changes in expiratory flow rates.     

Beryllium exposure and pulmonary function: a cross sectional study of beryllium workers

A cross sectional study of 297 white male workers employed in a large beryllium plant was conducted to test the hypothesis that long term exposure to beryllium is associated with decrements in pulmonary function. Spirometric measurement of pulmonary function, chest radiographs, and arterial blood gas measurements were collected. After controlling for age, height, and smoking in multivariate regression models, decrements in FVC and FEV1 were found to be associated with cumulative exposure to beryllium in the period up until 20 years before the health survey. These decrements were observed in workers who had no radiographic abnormalities. The alveolar-arterial oxygen difference was associated with cumulative exposure in the 10 years immediately before survey, after controlling for age and smoking. These findings suggest that beryllium may have both short and long term pulmonary effects that are distinct from the classic forms of acute and chronic beryllium disease.     

Respiratory disability in ex-cotton workers

A high proportion of textile workers handling cotton and flax complain of respiratory symptoms and show a loss in lung function. These effects are reversible in the early stages but the degree to which they lead to permanent respiratory disability is unknown. Two surveys were therefore conducted in which respiratory function and symptoms were compared in ex-textile workers and in control subjects who had never been exposed to textile dusts. One survey was of ex-flax workers in Northern Ireland. The present survey was of ex-cotton workers in Lancashire. A survey of random population samples in Oldham and Bolton, in both of which cotton had formerly been the most important source of employment, was conducted. After allowing for age, height, and smoking, lung function was about 2-8% lower in the ex-textile workers than in controls who had never been exposed to any dust. Ex-textile workers were slightly shorter than the controls, suggestive of past social and nutritional deprivation which may have contributed to the decrement in lung function. There was evidence of a small but increasing decrement in lung function with an increase in a "dust exposure" score. For men, about 15 years of heavy dust exposure was associated with a loss in FEV1 equivalent to that shown by light or ex-smokers. For women, 15 years of heavy dust exposure appeared to be associated with a decrement in FEV1 about half that of light smoking.