Successful human islet isolation utilizing recombinant collagenase

The enzymatic dissociation of acinar tissue by collagenase is a substantial step in the isolation of pancreatic islets. Although essential collagenase components have been purified, the variability in the activity of different batches limits long-term reproducibility of isolation success. The utilization of purified recombinant proteases would solve this problem. In the present study, pancreases from multiorgan donors were dissociated by means of digestion-filtration using either Liberase HI (n = 51) or a recombinant collagenase blend (n = 25). No significant differences were found regarding islet yield before and after purification, the percent of exocrine-attached islets, and final purity. However, the ratio between islet equivalents and islet numbers indicated a lesser fragmentation in islets isolated with recombinant collagenase (P < 0.01). In contrast, viability was slightly higher in islets isolated with Liberase (92.3 +/- 0.8 vs. 85.6 +/- 2.9%; P < 0.05). Insulin release during static glucose incubation was not different between experimental groups. Islet transplantation into diabetic nude mice resulted in sustained normoglycemia in either group until the graft was removed. These results demonstrated that viable human islets can be isolated using recombinant collagenase. Final optimization of this enzyme blend would offer continuous reproducibility of isolation success.     

Quantitative assessment of collagenase blends for human islet isolation

BACKGROUND: The variability in collagenase blends has been speculated as the single most important determinant of the success or failure in isolated islet yields in clinical islet transplantation. Examination of the formulation and potency of the widely used Liberase HI enzyme blend will uncover possible sources of imprecision. METHODS: High performance liquid chromatography (HPLC) and kinetic measurements of collagenase and protease activity were used to assess potency. Between four and nine clinical lots were assessed for various parameters such as relative formulation of collagenase isoforms, and recovered collagenase and protease potencies postreconstitution. RESULTS: Six vials from a single typical lot had a mean enzyme content of 489+/-62.5 mg (mean+/-SEM; range 398-610 mg). The mean recovered collagenase activity was 2235+/-310 Wünsch units (WU)/vial (range 1794-2968 WU/vial). The percent coefficients of variation for collagenase and protease activity in these vials were 17.4%, and 13.4%, respectively. The increase in the presence of the collagenase Ib (CIb) isoform detected by HPLC analysis was related to the chronological order of the date of manufacture. The CIb isoform was found to have a reduced specific activity compared to intact collagenase I (CI) (3.8+/-1.2 WU/mg vs. 2.1+/-0.7 WU/mg, P < 0.05). The presence of CIb was related to reduced islet yields in twelve human isolations studied. CONCLUSIONS: Variation in potency was observed between, and within lots of Liberase HI in this study. Differences in relative collagenase isoform composition may also affect the stability and potency characteristics of these blends.     

Factors that affect human islet isolation

More than 10,000 IEQ/kg recipient weight of islets is often necessary to achieve insulin independence in patients with type 1 diabetes mellitus. Several studies have identified high donor body mass index (BMI) and pancreas size as important factors for the success of human islet isolation. However, the donor shortage underscores the need to improve isolation outcomes from lower BMI pancreas donors and/or small pancreata. The aim of this study was to identify the critical factors that affect isolation outcome. We analyzed the data from 207 isolations performed from 2002 to 2006 with respect to donor characteristics, pancreas condition, and processing variables. More than 3000 IEQ/g pancreas weight was considered to be an acceptable isolation outcome. This goal was obtained from donors with a BMI >30 kg/m2 (P = .002). The pancreatic surface integrity was also a significant factor (P = .02). Moreover, longer digestion times (P = .04) and a greater proportion of trapped islets negatively affected success rates (P = .004). As previously reported, pancreata from high BMI donors were suitable for islet isolation and transplantation, as they yielded higher total islet particle numbers and higher IEQ/g. Although BMI and pancreas size are not controllable due to the organ donor shortage, factors such as pancreatic surface integrity, shorter digestion time, and lower proportions of trapped islets were found to be significant to obtain higher success rates. The development of better protocols and systematic training of processing/procurement teams will be of assistance to increase the number of successful human islet isolations.     

Evaluating the effect of serine proteases on collagenase activity during human islet isolation

Inconsistencies in human islet yields after collagenase digestion have been attributed to the activation of endogenous enzymes of the donor pancreas. It has been suggested that pancreatic serine proteases contribute to the proteolysis of collagenase. This study defined the effects of endogenous enzymes within the pancreas on pancreas dissociation during collagenase digestion. Levels of collagenase activity from samples taken throughout several steps in islet isolation procedures, both with and without the addition of the serine protease inhibitor Pefabloc, were determined by a spectrophotometric assay using N-[3-(2-furyl)acryloyl]-Leu-Gly-Pro-Ala as the substrate. Results clearly demonstrated that the level of collagenase activity remains stable throughout the isolation procedure despite differences in the donor factors from several cadaveric donor pancreases. This was further demonstrated by observing no difference in activity levels after incubating commercial collagenase preparations with serine proteases and analyzing by means of collagenase activity and SDS-PAGE. These data show that the presence of serine proteases does not affect the level of collagenase activity; however, they likely damage the islet cells upon prolonged digestion of the pancreatic tissue. Further efforts at examining exogenous and endogenous enzyme levels may result in the development of an enzyme cocktail that is both stable and effective for digesting the human pancreas while preserving islet function and viability.     

Improved human islet isolation by a tube method for collagenase infusion.

BACKGROUND: Collagenase infusion into the pancreatic duct is an essential step in human islet isolation. We developed a new method for ductal canulation and collagenese infusion. METHODS: A total of 53 pancreata were divided into two groups: group 1 (n=23), the new tube method, and group 2 (n=30), the standard angiocatheter method. In group 1, a polyethylene tube was inserted into the duct and pushed to the tail. The tail was first expanded, followed by expansion of the body and then the head, by pulling out the tube. RESULTS: Total islet number and number/g pancreas (mean+/-SE) were significantly higher in group 1 (481,123+/-43,218 and 8,010+/-722) (mean+/-SE) than in group 2 (300,974+/-35,122 and 5,090+/-515, P<0.01). Total islet equivalent number and islet equivalent number per gram pancreas were also significantly higher in group 1 (319,176+/-39,354 and 5,455+/-652) than in group 2 (202,022+/-23,331 and 3,722+/-468, P<0.04). Islet purity and fragmentation showed no differences between the groups. CONCLUSIONS: The tube method improved islet yields. We recommended this method for human islet isolation.     

Peri-insular presence of collagenase during islet isolation procedures.

Reportedly, higher islet yields are obtained by ductal collagenase administration and subsequent digestion of the pancreas than by the chopped tissue collagenase digestion technique. However, the exact mechanism of islet isolation is not known. This study aims to understand the underlying mechanism of a favorable effect of ductal collagenase administration. To this end, we investigated if the higher yields can be explained by a different distribution of the collagenase enzymes in the pancreatic tissue after ductal application as compared to during chopped tissue digestion. India ink was used to mimic and visualize the distribution of collagenase in histological sections of pancreases of several species. Ink particles were seen around and even within the islets both after ductal application and during chopped tissue collagenase digestion. Thus, collagenase enzymes are not restricted to the exocrine tissue compartment with either technique. In view of this observation, we compared the efficacy of both techniques in islet isolation procedures in paired experiments in rats. Both techniques gave similar islet yields to those reportedly obtained with the ductal collagenase method. However, with either technique, the islet yield was only approximately 50% of the endocrine volume of the pancreas, indicating that a substantial loss of islet tissue had occurred. We conclude that, irrespective of the route of collagenase administration, collagenase enzymes are present in the peri-insular space during islet isolation procedures. This is pertinent in view of the finding that both methods have similar islet yields in rats and that collagenase digestion, as such, is associated with loss of islet tissue.     

Serva collagenase NB1: a new enzyme preparation for human islet isolation

INTRODUCTION: Advances in the rate of success of human islet isolation are due in part to the availability of new purified enzyme blends. In this study we evaluated a new enzyme preparation composed of a highly purified collagenase that can be reproducibly blended with predetermined amounts of separately packaged neutral protease. METHODS: Nine human islet isolations were performed with collagenase NB1 supplemented with neutral protease (Serva Electrophoresis GMbH, group I). Yields, purity, morphology, in vitro function and islet cell apoptosis were assessed. The results were compared to those of nine human islet isolations performed with Liberase (Roche, group II) and matched for donor age, BMI, and circumstances of death. RESULTS: Islet yields were similar in both groups. However, islet equivalents (IE) per gram of pancreas and IE number to islet number were higher in group I (P <.05). Stimulation indices after insulin response to glucose (static incubation) were similar in both groups. Islet cell apoptosis rate was statistically significantly lower in group I. Islet morphology was significantly improved in group I with a higher proportion of intact islets. CONCLUSION: This new enzyme preparation (collagenase NB1 with neutral protease adjunct) was as effective as Liberase in terms of islet yields and function. Islet morphology was improved and rate of islet cell apoptosis was lower with this new collagenase. The absence of lot-to-lot variability in terms of neutral protease to collagenase ratio makes collagenase NB1 a promising enzyme for human islet isolation.     

Development of a novel digestion chamber for human and porcine islet isolation

BACKGROUND: The current technique of human pancreas digestion for islet isolation relies on selective distribution of collagenase delivered via the pancreatic duct to produce digestion and removal of peri-acinar fibrous tissue. However, the collagenase has relatively little effect on the interlobular fibrous tissue, which must therefore be broken down by mechanical means within the digestion chamber so as to release the contained acini and islets. The current way of achieving this in the Ricordi chamber is to place five or six stainless steel balls within the chamber and shake vigorously. The shaking presumably breaks down the interlobular fibrous tissue by a combination of shear force induced by the movement of tissue through the shaking process, assisted by numerous blows from the steel balls. Intuitively, one would expect some islets would be destroyed rather than released by such a battering. METHODS: In an attempt to improve the efficiency of islet isolation we have designed a new digestion/filtration chamber that consists of a glass cylinder, sealed with Teflon plates holding in mesh filters at each end, secured in place by a central threaded tie-rod and external knurled nuts. A ring-shaped piston within the cylinder can be pushed up and down the travel by two rods passing out through sealed ports in the Teflon disk at one end and connected to an external handle. The handle is used to gently push the piston up and down the travel of the cylinder, which pushes the fluid and tissue through the central lumen of the ring-piston. A series of hooks attached to the central tie-rod catch the fibrous strands of the passing tissue; the shearing forces produced cause disruption by a process thought to be similar to teasing the tissue apart with fine forceps. RESULTS: A series of initial experiments with human pancreas showed the prototype to be too large, causing temperature control problems, and a redesigned smaller chamber was produced, maintaining the crucial design features. Experience processing five human pancreata has now demonstrated that in three of five pancreata the new chamber produced a good yield (>200,000 I.E.) of remarkably well separated and intact islets, the entire dispersion process being under 1 hour. However, in two isolations the collagenase digestion was poor, with few free islets. A copy of the new chamber (reserved for porcine work only) has been produced, as well as a copy of the Ricordi chamber. We have confirmed that the new chamber can isolate porcine islets in large numbers (>5000 islets/g pancreas [n = 2], but note that pig islets are small). CONCLUSION: These preliminary studies are sufficiently encouraging to justify further direct comparison with the Ricordi chamber for the purpose of animal and human islet isolation.     

采用改良的胰腺三管插管法分离成人胰岛的实验研究

目的 探讨胰腺插管方式对成人胰岛分离及纯化的影响.方法 共对17例成人胰腺进行了胰岛的分离和纯化.采用改进的腹部器官联合快速切取技术获取胰腺,分别采用标准法(3例)、单管法(11例)和三管法(3例)对胰腺进行灌注.标准法是将胰腺从胰颈处完全切断,沿主胰管分别向胰头和胰尾插管,主胰管人十二指肠处予以结扎.单管法为采用加长插管自主胰管插入,直至胰尾.三管法是在胰颈背侧切开胰腺至主胰管,经主胰管分别向胰头和胰尾方向插管,在主胰管进入十二指肠处插第3根插管.采用胶原酶LibarseHI消化,Ficoll连续密度梯度离心法纯化.双硫腙染色,鉴定胰岛的纯度,并计算胰岛当量(IEQ).丫啶橙/溴乙啶荧光染色,计数活细胞百分率.体外葡萄糖刺激试验鉴定胰岛功能.结果 标准法的灌注量平均为0.71 ml/g胰腺,单管法的灌注量平均为0.96 ml/g胰腺,三管法的灌注量平均为1.24 ml/g胰腺,明显多于前两种方法(P＜0.05).标准法的胰岛收获量平均为1914 IEQ/g胰腺,单管法为2270 IEQ/g胰腺,三管法为2514 IEQ/g胰腺,单管法和三管法明显高于标准法(P＜0.05);其胰岛纯度/活性分别为74 ％/79.3％、75.6 ％/79.4％和78.3 ％/84.0％,三者间的差异无统计学意义.标准法所获得的胰岛胰岛素释放指数平均为3.46,单管法为4.74,三管法为5.27,单管法和三管法明显高于标准法(P＜0.05).结论不同的插管灌注方式对成人的胰岛分离有一定影响,三管法有利于提高胰腺灌注量,增加胰岛的收获量.     

国产胶原酶在小鼠胰岛分离中的效果研究#br#

目的 研究一种国产胶原酶在小鼠胰岛分离中的分离效果,探索该胶原酶在胰岛分离中应用的 可行性。方法 将国产胶原酶分别配成不同浓度的胶原酶溶液和含中性蛋白酶的胶原酶的溶液,经胰管逆行灌注胶原酶的方法进行小鼠胰岛分离,采用Ficoll液对胰岛进行纯化,计数所得的胰岛细胞团,培养 6 h后检测活性,对最佳分离结果的胰岛做同系糖尿病小鼠的肾被膜下移植,监测术后血糖和进行组织学 检查,以进口Sigma胶原酶V为对照。结果 国产胶原酶在小鼠胰腺消化时间、所得胰岛数量和活性效果 上跟进口胶原酶V有一定差距（P＜0.01）,但含中性蛋白酶的国产胶原酶组在小鼠胰岛分离数量和当量上 与进口胶原酶组无差异（P＞0.05）,分离的胰岛在体内移植后降血糖效果与进口胶原酶组无差异（P＞0.05）。 结论 国产胶原酶结合中性蛋白酶可用于小鼠胰岛的分离。     

Characterization of collagenase blend enzymes for human islet transplantation

BACKGROUND: Efficient islet isolation represents a necessary requirement for successful islet transplantation as a treatment for type 1 diabetes. The choice of collagenase for pancreas digestion is critical for the isolation outcome, and Liberase is the most widely used enzyme, although large intra-batched variability in activity and efficiency has been observed. METHODS: The aim of this study was to characterize Liberase components and their relative role in pancreas digestion. Liberase batches were characterized by microelectrophoresis. RESULTS: By means of microelectrophoresis, we identified three main proteins each with different prevalences between batches. Two proteins were found to correspond to class I (CI) and one to class II (CII) collagenase. In a series of 163 islet isolations, we observed that the CII correlated with islet yield (P<0.001) and digestion time (P<0.001); additionally, CI directly correlated with purity (P=0.028). Finally, when CII and one of the CI isoforms were >50 percentile, 15 of 36 preparations were transplanted, with 27 of 127 transplanted in the other cases (P=0.013). CONCLUSION: These results represent an important step toward the characterization of enzymes, with the final aim of identifying key components for a standardized product.     

Adjustment of the ratio between collagenase class II and I improves islet isolation outcome

BACKGROUND: Previous studies have clarified the distinct roles of collagenase class I (ccI) and class II (ccII) in enzymatic release of islets from pancreatic tissue. The present study sought to enhance the limited knowledge about the optimal ratio between collagenase classes. METHODS: Rat islets were isolated utilizing 0.4 DMC-U of neutral protease and 20 PZ-U of fractionated NB-1 collagenase recombined to obtain a ccII/I ratio of 0.5, 1.0, and 1.5. Quality control included assessment of yield (islet equivalents), trypan-blue exclusion, insulin release during static glucose incubation, and transplant function in diabetic nude mice. Data are expressed as mean values +/- SEM. RESULTS: Digestion time was only minimally influenced by different ccII/I ratios. The highest islet yield (P < .05) was obtained using a ccII/I ratio of 1.0. Purity and glucose stimulation index were only marginally affected by different ccII/I ratios. A significant loss of islet viability after 24-hour culture (P < .05) was observed only in islets isolated by means of a ccII/I ratio of 0.5 and 1.5 but not 1.0. Transplantation into diabetic nude mice revealed sustained islet graft function in all experimental groups. CONCLUSIONS: The present study indicates that the ratio between ccII and ccI is of significant relevance for optimizing islet yield and viability.     

Optimization of neutral protease to collagenase activity ratio for islet of Langerhans isolation

AIM: The optimal neutral protease to collagenase activity ratio has not been determined for islet isolation. We evaluated a new highly purified collagenase that can be blended with predetermined amounts of neutral protease (NP). METHODS: Islets were isolated from 7 groups of Sprague-Dawley rats. In group I, collagenase type XI (Sigma) at 2 mg/mL, and, in group II, Liberase at 0.6 mg/mL (2.4 PZ- U/mL; Roche) were used as controls. In groups III to VII, collagenase NB1 0.6 mg/mL (2.4 PZ-U/mL; Serva Electrophoresis) was used with increasing amounts of added NP. The NP to collagenase activity ratio (DMC-U/PZ-U) increased from 0.5% in group III to 2.0% in group VII. RESULTS: Mean islet equivalent (IE) yields per rat were 1367, 1755, 597, 895, 1712, 1043, and 905 in groups I to VII. IE yields were maximal at DMC-U/PZ-U = 1.2%. Islet morphology was influenced by NP concentration with decreasing numbers of trapped islets and increasing numbers of fragmented islets as NP contents increased. Cytokine release, islet cell apoptosis, and in vitro function were significantly better in groups III to VII as compared with groups I and II. CONCLUSION: NP is a crucial additive to collagenase for islet isolation. Optimization of the NP to collagenase activity ratio (1.2% in this model) improves yields and morphology after islet isolation.     

Deterioration and variability of highly purified collagenase blends used in clinical islet isolation

BACKGROUND: The quality and stability of enzyme blends used in islet cell processing are critical for successful human islet isolation. A wide variability in enzymatic activity among lots of Liberase HI has been reported. This study examines the interlot and intralot variability of Liberase HI and the over-time deterioration of enzyme quality based on the analysis of islet isolation outcomes. METHODS: The data of 169 human isolations processed for clinical islet transplantation, using five different lots of Liberase HI, were retrospectively analyzed. Inter- and intralot variables in the islet isolation were assessed over a 15-month period. RESULTS: The analysis revealed significant interlot differences in the digestion time, prepurification islet counts, percent recovery, viability, and glucose stimulation insulin index. Moreover, a significant decrease in the pre- and postpurification islet yield per pancreas weight (IEQ/g) in isolations processed by two different enzyme lots used over a 15-month period was observed, suggesting a progressive deterioration of enzyme quality. CONCLUSIONS: Our data demonstrate a significant lot-to-lot related variability in islet isolation outcomes. In addition, the over-time decline in isolation outcomes processed using a single enzyme lot was observed even when the enzyme blends were used within the expiration dating specified by the manufacturer.     

Donor and isolation variables predicting human islet isolation success

BACKGROUND: Recent advances in the fields of islet transplantation and in vitro islet cell expansion place a renewed emphasis on the optimization of islet isolation from cadaveric human donor organs. We retrospectively analyzed 171 islet isolations to identify variables that predict islet yield and isolation success. METHODS: Cadaveric human donor pancreata were procured and processed according to established protocols. Donor-, procurement-, and isolation-related variables were analyzed for correlation with islet yield and isolation success (> or =250,000 islet equivalents). RESULTS: Univariate analysis suggested correlations between islet yield and donor age (P<0.005), body surface area (P<0.005), duration of enzymatic digestion (P<0.001), and pancreatic beta-cell volume (P<0.05). Donor sex (P<0.01), procurement team (P<0.05), and peridigestion serine protease inhibition (P<0.05) affected islet yield, whereas enzyme lot (P<0.01) and pancreatic fatty infiltration (P<0.05) influenced isolation success. By logistic regression, donor sex and age, and duration of enzymatic digestion could predict a successful isolation with 72% accuracy. The use of Liberase CI improved islet yield (P<0.05) in young donors (< or =25 years). CONCLUSIONS: While donor-related variables are useful in predicting islet yield, these are likely surrogates for pancreatic beta-cell volume. Enzyme lot, and the associated duration of enzymatic digestion (P<0.05), appears to be key determinants of isolation success.     

三种消化酶在大鼠胰岛分离纯化中的效果比较

目的　分别用 3种酶消化大鼠胰腺 ,比较分离纯化后胰岛细胞的收获量、纯度、活性和功能。方法　将 2 1只SD大鼠按应用释放酶、胶原酶P、胶原酶V消化胰腺随机均分为A、B、C组。结果　A组的胰岛细胞收获量比B组或C组多 ( 93 0± 78比 692± 68或 70 6± 70 ,P <0 .0 5 ) ;纯度比B组或C组高 ( 93 .8± 2 .3比 88.4± 2 .0或 89.2± 2 .1,P <0 .0 5 ) ;成活率比B组或C组高( 97.2± 1.4比 92 .2± 1.9或 92 .9± 2 .1,P <0 .0 5 ) ;A组培养后胰岛素分泌量和葡萄糖刺激时胰岛素分泌量比B组或C组多 (P <0 .0 5 ) ;A组逆转糖尿病大鼠的高血糖状态时间比B组或C组长( 7.5± 1.3比 5 .8± 1.6或 6.3± 1.2 ,P <0 .0 5 )。结论　与胶原酶P和胶原酶V比较 ,释放酶消化大鼠胰腺可提高胰岛细胞的收获量、纯度、活性和功能。     

Technical improvement of human pancreatic islet isolation

INTRODUCTION: A key factor for successful islet isolation is to place the optimal amount of enzyme into the pancreatic ducts prior to starting digestion of pancreatic glands. To improve this procedure, we introduced novel techniques to identify and repair tissue damage resulting in leakage of collagenase solution. MATERIALS AND METHODS: One hundred twelve standardized consecutive islet isolations were for the effects of dye and glue on islet yield, islet function using a perifusion assay, and the possibility of clinical transplantation. One group of pancreata (n = 26) obtained en bloc together with duodenum were carefully detached with ligation of accessory ducts in an isolation unit (WPD group), whereas the pancreata were dissected from the duodenum in the operating room in the other 86 isolations. In 28 of 86 isolations, whole glands were used (WP group), while only the body and tail area were applied in the remaining 58 isolations (PP group). RESULTS: Both dye and glue effectively prevented leakage of collagenase from the gland. Both islet yield and success rate were higher with these tools without adverse effects on islet function or collagenase activity. The success rate of isolations and islet yield were significantly higher in the WPD group (P = .02 and .001, respectively). CONCLUSIONS: Dye and glue may be useful tools to improve human islet isolation procedures. In addition, the use of the whole pancreas further improves the outcome.