Lung function among asbestos cement factory workers: cross-sectional and longitudinal study

Ventilatory capacity tests and standardized respiratory questionnaires were used in 1973 and in 1980 to measure the effect of mixed dust exposure in the asbestos cement industry on respiratory symptoms and lung function in 65 exposed workers and 30 controls (exposed to polyvinyl chloride but not to asbestos). Workers exposed to asbestos had 1) a higher prevalence of breathlessness and chest pain, and a higher incidence of breathlessness; 2) lower 1980 values of forced vital capacity (FVC) (0.27-0.83 liters) and forced expiratory volume in 1 sec (FEV1) (0.23-0.62 liters); and 3) a faster decline (nearly 40 ml/year) in FVC and FEV1 between 1973 and 1980. The FVC annual decrease was 52.5 ml in the subjects with more than 15 years since first asbestos exposure, whereas it was 24.3 ml in those with less than 15 years, suggesting a faster decline after 15 years of exposure. The effect of asbestos exposure and smoking habits was less than additive as regards pulmonary function.     

Respiratory symptoms and lung function in jute processing workers: a primary investigation

This paper presents the results of an investigation of respiratory symptoms and lung function of 404 workers who had been exposed to jute dust in a jute mill. Measurement of total dust concentration and analysis of dust composition were also conducted. Most workers in the jute mill were exposed to jute dusts containing less than 5% silica, whereas a few workers were exposed to dusts containing approximately 10-15% silica. Male smokers and nonsmokers in the dust-exposed group had a higher prevalence of cough and chest tightness compared with those in the control group. Among dust-exposed workers, female nonsmokers had a significantly higher prevalence of cough, chronic bronchitis, chest tightness, and dyspnea than those in the control group. Lung function tests showed that dust-exposed workers had a greater incidence of abnormal lung function than did control workers, as measured by percentage of predicted forced vital capacity (FVC), forced expiratory volume in 1 s (FEV1.0), and FEV1.0/FVC. Dust exposure was the main cause of respiratory symptoms and abnormal values of FEV1.0, but both cigarette smoking and dust exposure contributed to the abnormal values reported for FEV1.0.     

Cement dust exposure and ventilatory function impairment: an exposure-response study

We investigated cumulative total cement dust exposure and ventilatory function impairment at a Portland cement factory in Tanzania. All 126 production workers were exposed. The control group comprised all 88 maintenance workers and 32 randomly chosen office workers. Exposed workers had significantly lower forced vital capacity (FVC), forced expiratory volume in 1 second (FEV1), peak expiratory flow rate (PEF), FEV1/FVC, FVC%, FEV1% and PEF%, than controls adjusted for age, duration of employment, height, and pack-years. Cumulative total dust exposure was significantly associated with reduced FVC, forced expiratory volume in 1 second, and peak expiratory flow rate adjusted for age, height and pack-years. Cumulative total dust exposure more than 300 mg/m year versus lower than 100 mg/m years was significantly associated with increased risk of developing airflow limitation (odds ratio = 9.9). The current occupational exposure limit for total cement dust (10 mg/m) appears to be too high to prevent respiratory health effects among cement workers.     

Decline in annual lung function in workers exposed to asbestos with and without pre-existing fibrotic changes on chest radiography.

OBJECTIVES--To examine whether or not workers with pre-existing mild pulmonary fibrosis have accelerated decline in forced expiratory volume in one second (FEV1) or forced vital capacity (FVC), under low level exposure to chrysotile asbestos. METHODS--All male workers in two asbestos manufacturing factories were followed up annually for six years to compare their declines in FEV1 and FVC. The values of FEV1 and FVC were divided by the square of the person's height to adjust for body size differences (FEV1/Ht2 and FVC/Ht2, respectively). Annual change was calculated for each subject as a slope of the simple linear regression with FEV1/Ht2 or FVC/Ht2 regressed according to age. Analysis was conducted on 242 middle aged workers who had normal routine spirometry values, normal chest radiographs or mild pneumoconiosis up to 1/2 grade, without changes either in smoking habit or severity of pneumoconiosis during the study period, and with acceptable spirograms in three or more surveys. The occupational environment, in terms of chrysotile asbestos, had been well controlled below the threshold limit value of Japan at that time--namely, 2 fibres/micromilligrams. RESULTS-There was no significant effect from the interaction between pre-existing mild pulmonary fibrosis and low level of exposure to chrysotile asbestos on the accelerated annual decline of FEV1/Ht2, or FVC/Ht2. Fibrosis significantly contributed to annual changes in FEV1/Ht2, even after adjustment for mean FEV1 and smoking. The point estimate of the contribution was - 4.9 ml/m2/y. No significant independent contribution of exposure was found in decline of either FEV1/Ht2 or FVC/Ht2. CONCLUSIONS--Pre-existing pulmonary fibrosis is an independent risk factor for accelerated annual decline of FEV1, even when mild and stable. Additional decline due to exposure to chrysotile asbestos is less probable if it is well controlled under the current threshold limit value.     

Dynamics of the lung function in asbestos pleural disease

As a rule, asbestosis is a disease of workers who are occupationally exposed to inhalation of asbestos dust, leaving permanent alterations on the lung parenchyma or pleura. In our ten-year study, we investigated 318 workers with pleural asbestosis from whom we took medical history which included occupational exposure to asbestos, radiological examinations and lung function, which is mandatory for the diagnosis and the follow up of the disease. We analysed functional parameters such as forced vital capacity (FVC) and forced expiratory volume in the first second (FEV1) and intermediate forced expiratory flow at 25% to 75% (FEF25%-75%). In addition, we investigated the predicted values of functional parameters according to smoking and non-smoking habits. We found a significant reduction in vital capacity, particularly in smokers after 25 years of exposure to asbestos. During the first 15 years, values of vital capacity on the group basis remained inside the 80% of the normal values and were not significant for assessing the dynamics of the lung function. To better assess the effects of occupational asbestos exposure, it is necessary to interpret lung function data not only on the group basis, but also for each subject individually.     

An epidemiologic study of the respiratory effects of trona dust

Trona (sodium sesquicarbonate) is mined from an underground deposit in Wyoming and processed for use in glass, paper, detergent, and chemical applications. Trona dust is alkaline (pH 10.5) and can have an irritant effect on respiratory airways, mucous membranes, and the skin. A study population of 142 underground miners and 88 surface workers from one facility volunteered for an epidemiologic study. Their mean age was 37.6 yr and mean duration of employment was 10.0 yr. The percentage with chronic cough and phlegm was 23%; both symptoms were more common among smokers than nonsmokers. Thirty-three percent of the workers complained of dyspnea when hurrying on level ground or walking up a slight hill. Half of the workers complained of upper respiratory tract symptoms and eye irritation. Both smokers and exsmokers had significant declines of forced expiratory volume in 1 sec (FEV1.0) with age; exsmokers also had declines with work-years when compared to a nonsmoking comparison population. Nonsmokers with personal dust measurements had a significant decline of FEV1.0 related to respirable dust exposure. A shift study of 104 workers revealed a significant fall in FEV1.0 among nonsmokers and surface workers. Significance was approached in the high dust exposure group. An increase in the mean percent predicted forced vital capacity and FEV1.0 was shown for the 125 workers who had a 5-yr follow-up of pulmonary function. There was no correlation between the shift study decrements and the longitudinal 5-yr follow-up. Industrial hygiene dust sampling found elevated levels of total dust but lower respirable dust, with no detectable free silica.     

A longitudinal study of lung function in jute processing workers.

A 5-y follow-up study of pulmonary function was conducted in 1982 and in 1987 for 50 current and retired jute-processing workers who had been employed for more than 10 y in a jute mill in China. Control subjects, who had no history of dust or gas exposure, were selected from a paper-packing plant in the same city. Forced expiratory maneuvers were conducted in the same manner in both 1982 and 1987. The jute workers' pulmonary functions, i.e., forced vital capacity (FVC), forced expiratory volume in 1 s (FEV1.0), and forced expiratory flow (FEF25-75%), were more compromised than were pulmonary functions in the controls for the same 5-y period; however, only the increased incidence of abnormal FEV1.0s in jute workers was statistically significant. Male jute workers had significantly higher annual decrements of FVC, FEV1.0, and FEF25-75% than did control workers. Regression analysis indicated that in 1987, predicted values of FEV1.0 and FEF25-75% for the jute workers were related to years of employment. Our results suggest that long-term exposure to jute dust could produce chronic loss of lung function.     

Is chronic airway obstruction from cotton dust exposure reversible?

BACKGROUND: Exposure to cotton dust is known to cause chronic airway obstruction, but there is little information on whether the obstructive impairment is reversible after the exposure stops. METHODS: Longitudinal changes in lung function were evaluated among 429 cotton textile workers and 449 silk workers in Shanghai, China, beginning in 1981. Both active and retired workers were tested every 4 to 6 years for 15 years. RESULTS: Overall, cotton workers had greater annual declines in forced expiratory volume in 1 second (FEV1) and forced vital capacity (FVC). Compared with active workers, retired cotton workers had lower annual loss of FEV1, although the retired workers had a greater loss during their active employment than the currently active workers. No such trends were detected in silk workers. Annual declines in FEV1 in retired cotton workers were smaller with increasing time since retirement. Multivariate analysis showed that retirement was a substantial contributing factor for improved FEV1 and FVC in the cotton workers, especially among those who did not smoke. Correspondingly, remission of airflow obstruction, defined as a ratio of FEV1 and FVC of less than 70%, was more common in retirees than in the active workers, and more common in nonsmokers than in smokers. CONCLUSION: Chronic airway obstruction related to long-term exposure to cotton dust may be partially reversible after the exposure ceases, although lung function does not return to the level found in unexposed workers.     

Work related decrement in pulmonary function in silicon carbide production workers.

The relation between pulmonary function, cigarette smoking, and exposure to mixed respirable dust containing silicon carbide (SiC), hydrocarbons, and small quantities of quartz, cristobalite, and graphite was evaluated in 156SiC production workers using linear regression models on the difference between measured and predicted FEV1 and FVC. Workers had an average of 16 (range 2-41) years of employment and 9.5 (range 0.6-39.7) mg-year/m3 cumulative respirable dust exposure; average dust exposure while employed was 0.63 (range 0.18-1.42) mg/m3. Occasional, low level (less than or equal to 1.5 ppm) sulphur dioxide (SO2) exposure also occurred. Significant decrements in FEV1 (8.2 ml; p less than 0.03) and FVC (9.4 ml; p less than 0.01) were related to each year of employment for the entire group. Never smokers lost 17.8 ml (p less than 0.02) of FEV1 and 17.0 (p less than 0.05) of FVC a year, whereas corresponding decrements of 9.1 ml (p = 0.12) in FEV1 and 14.4 ml (p less than 0.02) in FVC were found in current smokers. Similar losses in FEV1 and FVC were related to each mg-year/m3 of cumulative dust exposure for 138 workers with complete exposure information; these findings, however, were generally not significant owing to the smaller cohort and greater variability in this exposure measure. Never smokers had large decrements in FEV1 (40.7 ml; p less than 0.02) and FVC (32.9 ml; p = 0.08) per mg-year/m3 of cumulative dust exposure and non-significant decrements were found in current smokers (FEV1: -7.1 ml; FVC: -11.7 ml). A non-significant decrement in lung function was also related to average dust exposure while employed. No changes were associated with SO(2) exposure or and SO(2) dust interaction. These findings suggest that employment in SiC production is associated with an excessive decrement in pulmonary function and that current permissible exposure limits for dusts occurring in this industry may not adequately protect workers from developing chronic pulmonary disease.     

Work related decrement in pulmonary function in silicon carbide production workers

The relation between pulmonary function, cigarette smoking, and exposure to mixed respirable dust containing silicon carbide (SiC), hydrocarbons, and small quantities of quartz, cristobalite, and graphite was evaluated in 156SiC production workers using linear regression models on the difference between measured and predicted FEV1 and FVC. Workers had an average of 16 (range 2-41) years of employment and 9.5 (range 0.6-39.7) mg-year/m3 cumulative respirable dust exposure; average dust exposure while employed was 0.63 (range 0.18-1.42) mg/m3. Occasional, low level (less than or equal to 1.5 ppm) sulphur dioxide (SO2) exposure also occurred. Significant decrements in FEV1 (8.2 ml; p less than 0.03) and FVC (9.4 ml; p less than 0.01) were related to each year of employment for the entire group. Never smokers lost 17.8 ml (p less than 0.02) of FEV1 and 17.0 (p less than 0.05) of FVC a year, whereas corresponding decrements of 9.1 ml (p = 0.12) in FEV1 and 14.4 ml (p less than 0.02) in FVC were found in current smokers. Similar losses in FEV1 and FVC were related to each mg-year/m3 of cumulative dust exposure for 138 workers with complete exposure information; these findings, however, were generally not significant owing to the smaller cohort and greater variability in this exposure measure. Never smokers had large decrements in FEV1 (40.7 ml; p less than 0.02) and FVC (32.9 ml; p = 0.08) per mg-year/m3 of cumulative dust exposure and non-significant decrements were found in current smokers (FEV1: -7.1 ml; FVC: -11.7 ml). A non-significant decrement in lung function was also related to average dust exposure while employed. No changes were associated with SO(2) exposure or and SO(2) dust interaction. These findings suggest that employment in SiC production is associated with an excessive decrement in pulmonary function and that current permissible exposure limits for dusts occurring in this industry may not adequately protect workers from developing chronic pulmonary disease.     

Respiratory health of workers exposed to metal dusts and foundry fumes in a copper refinery.

OBJECTIVES--To assess airflow limitation in workers exposed long term to metal dust, the prevalence of pleural plaques in those workers exposed in the past to asbestos, the influence of pleural plaques on lung function, and the possible association with airway disease caused by asbestos. METHODS--A cross sectional and longitudinal (seven year) survey of 494 long term (mean (SEM) 21(1) years) workers in a copper refinery was carried out from medical questionnaires, chest radiographs, and forced spirometry. RESULTS--The prevalence of lifetime non-smokers was 19%, current smokers 39%, and ex-smokers 42%. The prevalence of chronic obstructive pulmonary diseases (COPD) (forced expiratory volume in one second (FEV1) < 80% predicted) was 5%, small airway dysfunction (SAD) (maximal mid-expiratory flow (MMEF) < 60% predicted) was 7%, and this did not differ from the control population. The COPD and SAD were associated with cumulative smoking index but not with the cumulative work years at the plant or with any type of work at the plant. The mean (SEM) reduction of FEV1 was 20(7) ml in non-smokers, 26(4) ml in smokers, and 26(5) ml in ex-smokers (P > 0.05). In the smokers and ex-smokers with COPD, the loss of FEV1 was 53(10) (P < 0.02). The prevalence of pleural plaques was 11% (P < 0.0001); pleural plaques were found in older workers with known exposure to asbestos. The pleural plaques were circumscribed and associated with a non-significant 196 ml reduction in forced vital capacity (FVC) and non-significant reduction of FVC over time. The pleural plaques were not associated with COPD or SAD. The cumulative smoking index obtained by a technician did not differ from that by a chest physician. CONCLUSIONS--Despite exposures to asbestos that produced pleural plaques and exposures to metal dusts and foundry fumes the long term workers of this plant did not have excessive prevalence of COPD or SAD. The data suggest that low level long term exposure to metal dusts, gases, and foundry fumes do not necessarily cause respiratory dysfunction, circumscribed pleural plaques with low grades of width and extent do not reduce FVC significantly, and exposure to asbestos dust that produced pleural plaques does not necessarily produce airway dysfunction.     

蔺草染土粉尘对工人肺功能的影响

[目的 ]了解蔺草染土粉尘对接触工人肺功能的影响。 [方法 ]随机选择接尘工龄 1年以上的工人作为调查对象 ,并选择无明显粉尘和毒物接触的工人作为对照 ,进行肺功能测定。 [结果 ]粉尘接触者肺功能各项指标明显低于对照组 ,FVC、FEV1.0 的异常检出率显著高于对照组。不吸烟者肺功能损伤程度与接触粉尘密切相关。 [结论 ]结果提示蔺草染土粉尘对工人肺功能有明显损伤 ,FVC、FEV1.0 、FEV1.0 %等可作为肺功能评价的首选指标     

Ventilatory function after exposure to various respirable hazards in a population of former coal miners

The ventilatory function of 406 male former coal miners who had presented at the Cook County Hospital occupational medicine clinic between January 1976 and April 1987 was studied to determine whether subsequent exposure to respiratory hazards after leaving the coal mines adversely affected lung function. The miners were divided into five exposure groups based on their exposure to respirable hazards. These were coal dust only, coal dust plus asbestos dust, coal dust plus silica dust, coal dust plus another respirable hazard and coal dust plus two other respirable dust exposures. Duration of employment in coal mines, race, smoking history, and mean age were not significantly different between the various exposure groups. No significant difference was found in the per cent of predicted forced expiratory volume in one second (FEV1), per cent of predicted forced vital capacity (FVC), and FEV1/FVC when the coal dust only group was compared with each of the other four exposure groups using ANOVA. Among former coal miners who present for a respiratory disability determination, therefore, exposure to respirable hazards subsequent to employment in coal mines is not associated with a statistically significant deterioration in ventilatory function.     

Ventilatory function after exposure to various respirable hazards in a population of former coal miners.

The ventilatory function of 406 male former coal miners who had presented at the Cook County Hospital occupational medicine clinic between January 1976 and April 1987 was studied to determine whether subsequent exposure to respiratory hazards after leaving the coal mines adversely affected lung function. The miners were divided into five exposure groups based on their exposure to respirable hazards. These were coal dust only, coal dust plus asbestos dust, coal dust plus silica dust, coal dust plus another respirable hazard and coal dust plus two other respirable dust exposures. Duration of employment in coal mines, race, smoking history, and mean age were not significantly different between the various exposure groups. No significant difference was found in the per cent of predicted forced expiratory volume in one second (FEV1), per cent of predicted forced vital capacity (FVC), and FEV1/FVC when the coal dust only group was compared with each of the other four exposure groups using ANOVA. Among former coal miners who present for a respiratory disability determination, therefore, exposure to respirable hazards subsequent to employment in coal mines is not associated with a statistically significant deterioration in ventilatory function.     

某煤业集团煤工尘肺病人肺通气功能分析

目的了解某煤业集团煤工尘肺病人和接尘非煤工尘肺病人肺通气功能损伤情况,探讨煤工尘肺病人不同工种、工龄、分期之间肺通气功能损伤的差异。方法选取某煤业集团确诊的煤工尘肺病人555名。另外选取该煤业集团555名接尘的非煤工尘肺病人和207名非接尘工人作为对照。采用统一的体检表格,由专业医师进行统一体检,并逐一填写表格。肺功能测定仪器为北京产AS.507型肺量计,进行肺通气功能指标测定。运用卡方检验、单因素方差分析、相关分析进行统计学处理。结果尘肺病人组肺功能异常率高于接尘非尘肺病人组和不接尘健康工人组,差异有统计学意义(χ2=193.319,P<0.001);采用单因素方差分析,三组人群各指标的比较结果显示,尘肺病人组的FEV1.0相对值和FEV1.0%低于接尘非尘肺病人组和不接尘工人组,尘肺病人组和接尘非病人组的FVC相对值均低于不接尘工人组。555名尘肺病人包括不吸烟108人、戒烟427人和吸烟20人,其肺功能异常率分别是67.6%、74.5%和90.0%(χ2=4.381,P=0.036<0.05),不吸烟组和吸烟组的FVC相对值均低于戒烟组,戒烟组的FEV1.0%明显低于不吸烟组。FEV1.0相对值在各组之间差异无统计学意义。各工种之间FVC相对值、FEV1.0相对值,FEV1.0%比较,差异均无统计学意义;各工龄组之间差异亦无统计学意义。各期别尘肺病人FVC相对值、FEV1.0相对值比较,差异无统计学意义,但贰期、叁期尘肺病人FEV1.0%高于壹期尘肺病人。结论接尘非煤工尘肺病人与煤工尘肺病人肺通气功能均有损伤,煤工尘肺病人肺通气功能损伤重于接尘非煤工尘肺病人,说明肺通气功能可以作为监测煤工尘肺的早期敏感动态观察指标。吸烟是影响肺通气功能的一个重要因素,吸烟加剧煤工尘肺病人肺通气功能的损伤程度。     

石棉工人肺通气功能变化的追踪研究

本研究通过对某石棉制品厂73例男性工人（其中健康石棉工人37例，石棉肺患者36例）分别于1984、1989及1994年进行了三次肺通气功能追踪测定，结果表明：石棉工人肺通气功能动态变化的特点是VC、FVC和FEV，进行性降低，FEV1／FVC％显著增高；石棉工人肺通气功能改变的早期阶段在接触石棉粉尘后10～15年期间；其肺通气功能损害的基本类型是限制型，在平均接尘15年后显示出典型的限制型特征。     

Exposure to cement dust at a Portland cement factory and the risk of cancer.

The relation between exposure to cement dust and cancer was examined in a population of 546 cement workers and a reference population of 858 randomly sampled men of similar age and area of residence. In 1974 all men gave lifelong occupational and smoking histories; information on incidence of cancer in the period 1974-85 was obtained from the Danish Cancer Registry. No increased risk of overall cancer was found among cement workers. Among men with more than 20 years exposure to cement dust, 14 cases of respiratory cancer were observed (observed/expected (O/E) 1.52, 95% confidence interval (95% CI) 0.90-2.57) when compared with all Danish men. Men with 1-20 years exposure had O/E 1.14 (95% CI 0.59-2.19) based on nine cases of cancer. After excluding all men with documented exposure to asbestos during employment in an asbestos cement factory no increased risk of overall cancer or respiratory cancer was found among cement workers compared with white collar workers from the local reference population, using a Cox regression model controlling for age and smoking habits. Relative risks were 0.5 (95% CI 0.1-1.5) and 1.0 (95% CI 0.4-2.6) for men with 1-20 and more than 20 years of exposure to cement dust respectively compared with white collar workers.     

Exposure to cement dust at a Portland cement factory and the risk of cancer.

The relation between exposure to cement dust and cancer was examined in a population of 546 cement workers and a reference population of 858 randomly sampled men of similar age and area of residence. In 1974 all men gave lifelong occupational and smoking histories; information on incidence of cancer in the period 1974-85 was obtained from the Danish Cancer Registry. No increased risk of overall cancer was found among cement workers. Among men with more than 20 years exposure to cement dust, 14 cases of respiratory cancer were observed (observed/expected (O/E) 1.52, 95% confidence interval (95% CI) 0.90-2.57) when compared with all Danish men. Men with 1-20 years exposure had O/E 1.14 (95% CI 0.59-2.19) based on nine cases of cancer. After excluding all men with documented exposure to asbestos during employment in an asbestos cement factory no increased risk of overall cancer or respiratory cancer was found among cement workers compared with white collar workers from the local reference population, using a Cox regression model controlling for age and smoking habits. Relative risks were 0.5 (95% CI 0.1-1.5) and 1.0 (95% CI 0.4-2.6) for men with 1-20 and more than 20 years of exposure to cement dust respectively compared with white collar workers.     

广州地区1606名粉尘作业工人的肺功能状况调查

目的明确粉尘暴露、年龄、工龄、吸烟对粉尘作业相关人员肺功能的影响,为尘肺病的防治和管理提供科学依据。方法抽取在广州市第十二人民医院接受体检并做肺功能检查项目的1606名粉尘作业人员作为观察组,同时抽取相同体检情况下的1606名非接尘人员作为参照组进行比较。结果 2组肺功能检查结果比较,观察组FVC为（87.37±10.29）、FEV1.0为（87.39±11.50）、FEV1.0/FVC为（83.57±16.86）,与对照组比较差异均有统计学意义（均P〈0.01））。对照组肺功能异常240例,异常发生率为14.9%;观察组肺功能异常583例,异常发生率为36.3%。其中观察组中水泥粉尘异常率最高（49.5%）,金属粉尘最低（30.3%）。职业粉尘暴露中电焊烟尘、金属粉尘、砂轮磨尘、水泥粉尘、煤尘、其他粉尘暴露均为肺功能异常的危险因素,其OR值及95%CI分别为2.58（2.00,3.33）、2.03（1.57,2.64）、3.16（2.06,5.47）、3.41（1.88,6.20）、2.29（1.35,3.88）、3.07（2.15,4.91）;职业粉尘暴露与工龄、吸烟存在协同作用,可使肺功能异常危险度增加（均P〈0.05）。结论广州地区各种主要粉尘暴露均会造成作业人群的肺功能明显下降,建议积极开展戒烟及针对长工龄作业工人采取更完善的个人监护措施。