Comparative study of the smooth muscle contractor activity of airborne dusts and of dustiness in cotton, flax, and jute mills.

A bioassay technique using isolated guinea-pig ileum was employed to compare the smooth muscle contractor activity of various dusts from mills in which the prevalence of byssinosis was known. The activity of dust from a mill spinning a coarse grade of cotton was several times greater than that in dust from a mill processing a fine grade of cotton. There was a similar order in the difference of the prevalence of byssinosis in these mills. However, the activities of fine cotton, flax, and jute dusts were very similar to each other, in spite of marked differences in the prevalence of byssinosis in these mills. For cotton dust, smooth muscle contractor activity was associated with all particle sizes, although the lowest level of activity was found in the largest sized fraction (less than 2 mm). Activity in the cotton dust extracts was not correlated with nitrogen, carbohydrate, or potassium content. However, about one-fifth of the activity of a cotton dust extract was associated with an insoluble particulate fraction. The possible chemical nature of the water-soluble contractor agent is discussed. It is concluded that, until the role of this agent in the pathogenesis of byssinosis has been established, the bioassay technique cannot be employed as a means of assessing the byssinogenic potential of cotton dust.     

Comparative study of the smooth muscle contractor activity of airborne dusts and of dustiness in cotton, flax, and jute mills.

A bioassay technique using isolated guinea-pig ileum was employed to compare the smooth muscle contractor activity of various dusts from mills in which the prevalence of byssinosis was known. The activity of dust from a mill spinning a coarse grade of cotton was several times greater than that in dust from a mill processing a fine grade of cotton. There was a similar order in the difference of the prevalence of byssinosis in these mills. However, the activities of fine cotton, flax, and jute dusts were very similar to each other, in spite of marked differences in the prevalence of byssinosis in these mills. For cotton dust, smooth muscle contractor activity was associated with all particle sizes, although the lowest level of activity was found in the largest sized fraction (less than 2 mm). Activity in the cotton dust extracts was not correlated with nitrogen, carbohydrate, or potassium content. However, about one-fifth of the activity of a cotton dust extract was associated with an insoluble particulate fraction. The possible chemical nature of the water-soluble contractor agent is discussed. It is concluded that, until the role of this agent in the pathogenesis of byssinosis has been established, the bioassay technique cannot be employed as a means of assessing the byssinogenic potential of cotton dust.     

The Pharmacological Activity of Extracts of Cotton Dust

Aqueous extracts prepared from dust collected in the card-rooms of several cotton mills have been prepared and found to contain activity which contracts the smooth muscle of guinea-pig ileum, guinea-pig trachea, rat stomach strip, and rat duodenum. The extracts contained an unknown contractor substance which was dialysable, resistant to boiling for one hour, and not destroyed by the action of proteolytic enzymes. They also contained a small amount of 5-hydroxytryptamine. One of the dust samples also contained histamine, but it could not be detected in the other samples, one of which was known to possess bronchoconstrictor properties in man. The particulate material, even after repeated washing, was found to have some stimulant action on guinea-pig ileum.

There was no evidence for the release of histamine by the extracts in either cats or guinea-pigs, although a very small amount was released in rats. Jute dust is much less active than cotton dust, and the activity differs qualitatively. Cotton dust extracts were found to have pyrogenic activity but it is unlikely that pyrogens were responsible for the smooth-muscle contractor properties. Experiments with whole animals suggest that although smooth-muscle contracting substances were present in the extracts, it is possible that the symptoms of byssinosis are caused by the release of some other active bronchoconstrictor substance in the tissues. The mechanism of the release is not known; it may be caused by a soluble principle in the extract or due to the presence of particulate matter in the dust.

     

Relationships between dust level and byssinosis and bronchitis in Lancashire cotton mills

Berry, G., Molyneux, M. K. B., and Tombleson, J. B. L. (1974). British Journal of Industrial Medicine,31, 18-27. Relationships between dust level and byssinosis and bronchitis in Lancashire cotton mills. A prospective survey of workers in 14 cotton and two man-made fibre spinning mills was carried out. A questionnaire on respiratory symptoms was completed at the start of the survey by 1 359 cotton workers and 227 workers in man-made fibre mills and again two years later by about half of these workers. Dust measurements were available for 772 women and 234 men cotton workers.

The prevalence of bronchitis was found to be unrelated to dust level but for women was related to years of exposure. The change in symptoms of bronchitis was unrelated to dust level or to length of exposure. There was, however, an increased prevalence of bronchitis in the cotton mills when compared with the man-made fibre mills, and also over the two-year period a greater proportion of symptom-free workers developed symptoms and a lower proportion of those with symptoms lost their symptoms in the cotton mills than in the man-made fibre mills.

The prevalence of byssinosis was related to smoking habits, the smokers having about 1·4 times as much byssinosis as the non- and ex-smokers after allowing for exposure. Byssinosis was associated with the dust level and years of exposure, more so for the women, and an association between the incidence of new cases over the two years and dust level was also found. After allowing for dust level, years of exposure, and smoking there were still differences between the occupational groups in byssinosis prevalence. Strippers and grinders had the highest prevalence followed by drawframe tenters. Speedframe tenters, card tenters, and comber tenters had similar prevalences and ring spinners the lowest.

     

Byssinosis in the Waste Cotton Industry

This paper is of some historical interest. It describes an investigation to determine whether byssinosis occurred among workers in the waste cotton industry. It was undertaken in 1950 at the instigation of the Minister of National Insurance.

The materials used in the industry were (1) cotton that had been previously spun, and (2) waste material discarded during the preparations for spinning higher grades of yarn. A proportion of raw cotton was sometimes blended with the waste.

Twenty-two mills, representative of the industry, were surveyed. All the men in these mills, who were over 35 years of age and with at least 10 years' exposure to cotton dust, were seen. The investigations included a work history, a clinical examination, an assessment of effort dyspnoea, and a chest radiograph.

There were 140 men who had never been exposed to any dust hazard other than waste cotton. In this group were found seven (5%) men with disabling byssinosis and 35 (25%) men with lesser degrees of the same disease. There were also 15 (11%) men with bronchitis or emphysema without byssinosis.

Thus it was established that byssinosis did occur in the waste cotton industry. Insurance cover, under the National Insurance (Industrial Injuries) Act, 1946, was subsequently extended to workers in the waste cotton industry.

The survey provided no evidence that either the type of waste cotton processed or an admixture of raw cotton played a significant part in the aetiology or incidence of the disease.

     

A study of the acute and chronic changes in ventilatory capacity of workers in Lancashire cotton mills

Berry, G., McKerrow, C. B., Molyneux, M. K. B., Rossiter, C. E., and Tombleson, J. B. L. (1973).Brit. J. industr. Med.,30, 25-36. A study of the acute and chronic changes in ventilatory capacity of workers in Lancashire cotton mills. A prospective study of workers in 14 cotton and two man-made fibre spinning mills in Lancashire was carried out over a three-year period. A questionnaire on respiratory symptoms was completed at the start of the survey and again two years later. Up to six measurements of ventilatory capacity were made at six-monthly intervals. From these measurements the rate at which the forced expiratory volume (FEV₁) was declining (annual decline in FEV) was evaluated for 595 subjects. Six of the mills were visited on Mondays and in 199 operatives the ventilatory capacity was measured at both the beginning and end of the shift to evaluate its acute fall during work (Monday fall in FEV).

The mean annual decline in FEV for cotton workers was 54 ml/year and it was only 32 ml/year for workers in the man-made fibre mills but this lower value was attributable almost entirely to one of the two mills. For the jobs near the carding engines the annual decline was 22 ml/year higher than for speed-frame tenters. The annual decline for cigarette smokers was 19 ml/year greater than for non- and ex-smokers. The annual decline in FEV was not found to be related to symptoms of byssinosis or bronchitis, nor to present dust levels, bioactivity of the dust or air pollution, although the expected effect attributable to byssinosis turned out to be less than that which the survey was designed to detect.

The mean Monday fall in FEV was higher in cotton mills than in man-made fibre mills among those without symptoms of byssinosis and was correlated with present dust levels. For those with symptoms of byssinosis an increased Monday fall was found only in those processing coarse cotton.

For those subjects who completed the respiratory questionnaire on two occasions the chronic and acute changes in FEV were examined in relation to the change in symptoms of byssinosis. No association was found for annual decline in FEV but the Monday fall in FEV was greater for those who developed byssinosis during the survey than for those who remained free of symptoms, and was less for those who lost their symptoms than for those who retained them.

     

BYSSINOSIS IN CARDROOM WORKERS IN SWEDISH COTTON MILLS

The prevalence of byssinosis and chronic respiratory symptoms was studied in 117 workers in four Swedish cotton mills. Changes of forced expiratory volume in 0·75 sec. (F.E.V._0·75) during a Monday and a Wednesday were assessed in 64 male workers in four cardrooms in these mills. Dust sampling was performed with weighed millipore filters.

Prevalences of byssinosis as judged from the workers' histories were 68%, 55%, 44%, and 25% in the four mills; the lowest prevalence of 25% was found in a mill spinning both high grade cotton yarn and rayon. Among 67 workers in the mills having a byssinosis prevalence of 68% and 55%, 60% were non-smokers, 70% had chronic cough, and 27% had chronic dyspnoea. The F.E.V._0·75 decreased on Monday in workers who gave a history of Monday dyspnoea, and to a lesser degree, but still significantly, in those who did not.

In spite of marked differences in fine dust (i.e., dust smaller than 2 mm. diameter) concentrations in the four cardrooms, no significant relations between dust content, byssinosis prevalence, and F.E.V._0·75 changes on Monday could be demonstrated.

The prevention and treatment of byssinosis is discussed. Workers at risk should receive a periodical medical examination including at least a spirographical pulmonary function test at intervals of one year or less.

     

Byssinosis in Carding and Spinning Workers

Symptoms of byssinosis were found in 25% of 59 carders and in 12% of 99 spinners employed in two air-conditioned cotton textile mills. In carders as well as spinners, forced expiratory volume (FEV_1.0) and flow rates on maximum expiratory flow-volume (MEFV) curves decreased during work on Monday, and to a lesser extent on Wednesday. The prevalence of byssinosis in these mills is higher than would be expected according to previous data, on the basis of the relatively low dust concentrations in the carding and spinning areas. If these prevalence rates are valid for the US cotton textile industry in general, about 8,000 carders and 9,000 spinners have byssinosis (all grades). This estimate excludes retired workers.     

A Clinical and Environmental Study of Byssinosis in the Lancashire Cotton Industry

The prevalence of byssinosis was measured in a population of 189 male and 780 female workers employed in three coarse and two fine cotton mills. Ninety-eight per cent. of the male and 96% of the female population were seen.

The workers were graded by their histories as follows:

Grade 0—No symptoms of chest tightness or breathlessness on Mondays

Grade ½—Occasional chest tightness on Mondays, or mild symptoms such as irritation of the respiratory tract on Mondays

Grade 1—Chest tightness and/or breathlessness on Mondays only

Grade 2—Chest tightness and/or breathlessness on Mondays and other days

The dust concentrations to which the workers were exposed were measured with a dust-sampling instrument based on the hexhlet. Altogether 505 working places were sampled. In the card-rooms of the coarse mills 63% of the men and 48% of the women had symptoms of byssinosis. In the card-rooms of the fine mills the corresponding prevalences were 7% for the men, and 6% for the women. Prevalences were low in the spinning-rooms in the coarse mills. The mean dust concentrations in the different rooms ranged from 90 mg./100 m.³ in one section of the card-room in a fine mill, to 440 mg./100 m.³ in one of the card-rooms of the coarse spinning mills. The prevalence of byssinosis in the different rooms was closely related to the overall dustiness (r = 0·93). For the three main constituents of the dust, namely, cellulose, protein, and ash, the prevalence of byssinosis correlated most highly with protein, particularly with the protein in the medium-sized dust particles, i.e., approximately 7 microns to 2 mm.

The symptoms of byssinosis may be caused by something in the plant débris which affects the respiratory tract above the level of the terminal bronchioles. This is the site where the medium-sized dust deposits. The possible importance of the fine dust is discussed.

For routine measurements in industry, it is necessary to have a method of assessing dustiness in which the sampling equipment is simple and assessment rapid. As total dust concentration is relatively easy to measure, and correlates closely with the prevalence of byssinosis, permissible levels of dustiness have been expressed in terms of total dust. On comparing the prevalence of byssinosis among workers with short and long exposures and low and high concentrations (Table 11), it appears that a mill with a concentration of 100 mg./100 m.³ or less would be reasonably safe, but in dusty card-rooms it seems that such levels are not possible to achieve at present. As it is necessary to adopt a realistic target that can be achieved, it is suggested that dust concentrations in cotton mills should be less than 250 mg./100 m.³ and that periodic medical examinations should be adopted to protect susceptible workers who can be advised to leave their dusty environment before they are permanently disabled.

     

Prevalence of byssinosis in Swedish cotton mills.

The prevalence of byssinosis and of chronic bronchitis was studied in a questionnaire investigation among workers in bale opening areas, carding rooms, and spinning rooms in five Swedish cotton mills. Airborne dust and Gram-negative bacteria was measured. Nineteen per cent of the interviewed workers reported symptoms of light byssinosis (grade 1/2). The prevalence of symptoms was not related to the duration of employment, and cases of byssinosis were found among people who had worked in cotton mills for only a few years. A significantly higher proportion of male than female workers reported symptoms. No difference in the extent of byssinosis was found between smokers and non-smokers, but the prevalence was significantly higher among those workers who had ceased smoking. The prevalence of byssinosis was related to the number of airborne viable Gram-negative bacteria as well as to the dust level in the different mills.     

The Relationship of Byssinosis to the Bacteria and Fungi in the Air of Textile Mills

The principal causative agent of byssinosis lies in the dust of cotton mills. This dust contains bacteria and fungi. An attempt has been made to determine whether any association could be established between the numbers of viable bacteria and fungi in the air of two cotton and two jute mills, and the prevalence of byssinosis. No association was found except between the numbers of live organisms of B. pumilus and B. subtilis, and the occurrence of byssinosis. This association does not establish a causal relationship, but it is suggested that an attempt should be made to produce typical symptoms in byssinotic subjects by means of organisms of the genus Bacillus. A subsequent paper presents the results of some observations of this kind.     

Respiratory symptoms and cotton dust exposure; results of a 15 year follow up observation

Aims: To determine chronic effects of long term exposure to cotton dust and endotoxin on incidence of respiratory symptoms and the effect of cessation of exposure.

Methods: Respiratory health in 429 Chinese cotton textile workers (study group) and 449 silk textile workers (control group) was followed prospectively from 1981 to 1996. Byssinosis, chest tightness, and non-specific respiratory symptoms were assessed by means of identical standardised questionnaires at four time points. Exposures to cotton dust and endotoxin were estimated using area samples collected at each survey. Incidence and persistence of symptoms were examined in relation to cumulative exposure and exposure cessation using generalised estimating equations (GEE).

Results: Among cotton workers, the cumulative incidence of byssinosis and chest tightness was 24% and 23%, respectively, and was significantly more common in smokers than in non-smokers. A high proportion of symptoms was found to be intermittent, rather than persistent. Among silk workers, no typical byssinosis was identified; the incidence of chest tightness was 10%. Chronic bronchitis, cough, and dyspnoea were more common and persistent in the cotton group than in the silk group. Significantly lower odds ratios for symptoms were observed in cotton workers who left the cotton mills; risk was also related to years since last worked. Multivariate analysis indicated a trend for higher cumulative exposure to endotoxin in relation to a higher risk for byssinosis.

Conclusion: Chronic exposure to cotton dust is related to both work specific and non-specific respiratory symptoms. Byssinosis is more strongly associated with exposure to endotoxin than to dust. Cessation of exposure may improve the respiratory health of cotton textile workers; the improvement appears to increase with time since last exposure.

     

A chemical and engineering analysis of dust in textile mills

Proximate chemical analysis was conducted on the carding, spinning and weave rooms of textile mills. The dust was found to be composed of inorganic, cellulosic and noncellulosic organics in carding and spinning. The percentage of noncellulosic organic (the component of cotton dust considered to be responsible for byssinosis in cotton textile workers) in ring spinning was found to be one-half the percentage composition of the card room dust. The cellulosic percentage of spinning room dust is elevated above that found in card rooms. In weave rooms the composition of dust is a function of the fabric being produced, environmental control systems, and machinery. In all weave rooms where dust levels were sufficiently above background, all components of the dust were accounted for by the proximate chemical analysis without the presence of a noncellulosic organic component. The card room, spinning room and weave room produce dusts that are very different in composition, to the extent that the proximate chemical analysis could identify the area of origin of dust samples from a textile mill.     

An epidemiological study of respiratory symptoms in Lancashire mills, 1963-66

Molyneux, M. K. B., and Tombleson, J. B. L. (1970).Brit. J. industr. Med.,27, 225-234. An epidemiological study of respiratory symptoms in Lancashire Mills, 1963-66. An epidemiological study of card and blowroom workers in 14 cotton spinning and two man-made fibre spinning mills in Lancashire has been carried out on a prospective basis of six-monthly examinations over three years. The number of operatives to be included was decided so as to give a sufficient sample for the statistical assessment of fall in FEV, at the same time allowing for population movement. The examination of each worker included a history, a questionnaire of respiratory symptoms, and a measurement of forced expiratory volume in one second. The results in this paper, which will be followed by others on other aspects of the survey, give the prevalence of both byssinosis and bronchitis, according to the definition given, in the 1 359 cotton workers and 227 man-made fibre workers, seen at least once, and also the dust levels in the mills. Eight of the mills processed coarse and six medium cotton.

The total prevalence of byssinosis, as defined, is 26·9%, being higher in coarse than in medium cotton mills, and the occupational groups most affected are strippers and grinders, carders and undercarders, and draw frame tenters. In coarse mills symptoms develop in some men and women within the first four years of exposure, and in medium mills between five and ten years' exposure. Repeat questionnaires in about half the population, two years after the first questionnaire, showed the development of symptoms of chest tightness in an appreciable number not previously affected. The incidence of bronchitis is increased in operatives with symptoms of byssinosis, but is influenced by age and smoking.

Total dust levels averaged 3·1 mg/m³ in coarse miles and 1·2 mg/m³ in medium mills. The findings indicate that dust control measures, though they have produced considerable improvement, are not now fully effective with present methods of production.

     

Byssinosis in the Egyptian Cotton Industry: Changes in Ventilatory Capacity during the Day

A study in Egypt of 99 male cotton workers in a cotton ginnery and spinning mill, and of a control group of 12 power station workers, showed that the groups exposed to cotton dust had significantly greater falls in indirect maximum breathing capacity (I.M.B.C.) during the shift than groups not exposed to dust. Long-term effects of exposure to cotton dust were studied by examining the I.M.B.C.s measured at the beginning of the shift after adjustment to allow for differences in age and sitting height. The adjusted mean value for those with byssinosis was 10·1 litres/min. lower than for normal cotton workers and 19·6 litres/min. lower than for the power station workers. Four men were judged by their breathlessness on slight exertion and low ventilatory capacities to be seriously disabled with byssinosis.

In four other mills, all spinning similar types of cotton, changes in I.M.B.C. during the shift correlated highly with dust concentrations and indicated a safe level of dustiness of 1 mg./m.³ (total dust) at which the effects on ventilatory capacity were minimal.

     

Experimental Byssinosis

The symptoms of byssinosis were produced experimentally in one of three cotton-mill workers with pronounced byssinosis, by a dust prepared from leaves of cotton plants. Dusts of calcium carbonate, bacteria, and fungi did not reproduce the symptoms. Two mild cases of byssinosis and two cases of chronic bronchitis did not react specifically to any of these dusts.     

Effects of different vegetable dust exposures

Valić, F., and Žuškin, E. (1972).Brit. J. industr. Med.,29, 293-297. Effects of different vegetable dust exposures. In order to establish the rank of biological activity of vegetable dusts, five groups of non-smoking female workers exposed to similar concentrations of hemp, flax, cotton, sisal, and jute airborne dust, respectively, were compared as to the prevalence of byssinosis, chronic respiratory symptoms, and one-second expiratory volume changes over the Monday shift. The groups were selected in such a way as to differ in the distribution of age and length of exposure to the respective dust as little as possible.

The prevalence of byssinosis in hemp and flax workers was approximately equal (44% and 43% respectively), in cotton workers it was considerably lower (27%), while no byssinosis was caused by either sisal or jute dust. The highest prevalence of other chronic respiratory symptoms was recorded in hemp workers (39%), followed by flax (36%) and cotton workers (27%), while in sisal (13%) and jute workers (13%) it was the lowest.

Significant mean FEV_1·0 reductions over the shift were recorded in all the groups of textile workers with the largest reductions in hemp workers (19%) followed by flax (11%), cotton (8%), sisal (7%), and jute workers (5%). The application of orciprenaline before the shift diminished the mean acute FEV_1·0 falls over the work shift in all the groups studied.

     

Mill effect and dose-response relationships in byssinosis.

Four hundred and eighty-six textile workers in three cotton mills and one wool/synthetic mill were studied for symptoms and functional effects of workroom exposure to dust. Byssinosis was found in 5.7% of 386 cotton workers, with an apparent threshold level of 0.5 mg cotton dust/m3 of air. Mean post-shift functional declines were greater in workers exposed to greater than or equal to 0.2 mg/m3. Workers with byssinosis were unequally distributed, however, with respect to job category and mill; and these variables, rather than current dust exposure levels, accounted for the observed distribution of byssinosis prevalence rates. Variation in biological potency of different samples of cotton dust could be responsible for 'mill effect', the residual variation in response rates by mill after controlling for variation due to dust exposure. A number of other potential influencing variables that are likely to be distributed unequally by mill should also be considered. Mill effect should be assessed in large-scale studies of byssinosis, most of which have analysed biological response rates by combining mill and other variables to examine first-order effects of dust dosage. In such analyses, much of the observed variability may be due to factors other than dust dosage.     

Mill effect and dose-response relationships in byssinosis

Four hundred and eighty-six textile workers in three cotton mills and one wool/synthetic mill were studied for symptoms and functional effects of workroom exposure to dust. Byssinosis was found in 5.7% of 386 cotton workers, with an apparent threshold level of 0.5 mg cotton dust/m3 of air. Mean post-shift functional declines were greater in workers exposed to greater than or equal to 0.2 mg/m3. Workers with byssinosis were unequally distributed, however, with respect to job category and mill; and these variables, rather than current dust exposure levels, accounted for the observed distribution of byssinosis prevalence rates. Variation in biological potency of different samples of cotton dust could be responsible for 'mill effect', the residual variation in response rates by mill after controlling for variation due to dust exposure. A number of other potential influencing variables that are likely to be distributed unequally by mill should also be considered. Mill effect should be assessed in large-scale studies of byssinosis, most of which have analysed biological response rates by combining mill and other variables to examine first-order effects of dust dosage. In such analyses, much of the observed variability may be due to factors other than dust dosage.     

The health investigation of cotton textile workers in Beijing

This study reports findings from a survey of byssinosis among 289 cotton workers in certain cotton textile mills in Beijing. Incidence of byssinosis was 4.2% (12 cases). It decreased with a lower concentration of cotton dust and increased with yearly increment of cotton dust exposure. An elevation in body temperature over 37 degrees C was present among 14.2% of the workers on the first working day after rest. Acute lung function decrement was related to high dust concentration in the rooms. The higher the dust concentration in the rooms, the more evident was the chronic lung function decrement. Chronic bronchitis in cotton workers was higher than in controls. Incidence of byssinosis in smoking cotton workers was higher than in nonsmoking cotton workers.