Complete tracheal stenosis following percutaneous tracheostomy

Percutaneous tracheostomy is an effective method of airway management in the critically ill patient, avoiding an open exposure of the trachea. This method is time and cost-efficient and is used in many intensive care units. However, we would like to draw attention to one serious potential complication of this technique. This case report describes a case of complete tracheal stenosis above the level of tracheostoma as a direct result of the procedure. The aetiology of the stenosis as well as the surgical and postoperative managements is discussed.     

Tracheoplasty for long segment congenital tracheal stenosis: analysis of 29 patients over two decades

Purpose: The authors determined the long-term outcome of patients who underwent surgical repair of long-segment congenital tracheal stenosis (LCTS) and compared the quality of cartilage graft and slide tracheoplasty techniques.Methods: Twenty-nine patients underwent surgical repair of LCTS at 29 days to 9 years of age. In 26 patients, more than 50% of the entire length of the trachea was involved. The early 12 patients (1981 through 1992) were treated with a costal cartilage graft for tracheal reconstruction. The remaining 17 patients (1997 through 2002) were treated with slide tracheoplasty. For both procedures, a median sternotomy was preferred because of convenience when using extracorporeal circulation and for simultaneous repair of associated cardiovascular anomalies.Results: Of the 12 patients who underwent a costal cartilage graft, 8 survived (66%). Six of these patients are free of disease, but 2 have persistent airway problems. Three patients died of residual stenosis and 1 of unrelated disease. Of the 17 patients who underwent slide tracheoplasty, 13 survived (76%), and 10 are free of disease. Three patients continue to require a stent because of tracheomalacia and granulation. Two patients died of cardiac failure, 1 of granulation, and 1 of aspiration pneumonia.Conclusions: The authors challenged LCTS with a unique surgical approach and succeeded in making an incurable disease curable. When the cartilage graft technique is compared with slide tracheoplasty, however, the latter is preferable because it preserves native tracheal tissue with less frequent complications.     

Oesophageal balloon tracheoplasty in early tracheal stenosis following percutaneous tracheostomy

Percutaneous tracheostomy is an efficient technique used in intensive care units. Although a safe procedure, serious early and late complications can occur. A rare complication is suprastomal stenosis following inadvertent tracheal cartilage fracture resulting in stenosis. Management is complicated, often requiring specialised equipment. While surgical treatment techniques are evolving, none are universally applicable. We report a case of early tracheal stenosis following percutaneous tracheostomy, treated successfully using a novel technique of oesophageal balloon tracheoplasty. To our knowledge, this is the first reported case of immediate post percutaneous tracheostomy suprastomal stenosis treated with balloon tracheoplasty using an oesophageal balloon catheter which is readily available in most endoscopy units.     

Tracheoplasty for congenital stenosis of the entire trachea

Congenital stenosis involving the entire length of the trachea has generally been regarded as a fatal disease. Tracheoplasty using costal cartilage grafts to enlarge the lumen was successfully employed in such a case, and the technique is described. A 12-mo-old female was referred with recurrent severe respiratory distress since birth. By tracheoscopy and bronchography, the entire trachea was seen to be stenotic. The left bronchus was of normal caliber by bronchogram and the left lung was over inflated, while the right lung was aplastic. Through a midsternal thoracotomy, the left bronchus was incised and cannulated for ventilation. Longitudinal incision of the entire length of the anterior wall of the trachea permitted the advance of a nasotracheal tube along the inner surface of the divided trachea to the carina. Two pieces of costal cartilage were used to fill the defect in the anterior wall of the trachea. The grafts were attached to the tracheal edges by interrupted 5-0 Dexon sutures. The endotracheal tube was successfully removed two months later. The subsequent course of the patient has been satisfactory.     

Incidence of tracheal stenosis and other late complications after percutaneous tracheostomy

OBJECTIVE: To determine the incidence of tracheal stenosis, voice and breathing changes, and stomal complications after percutaneous dilatational tracheostomy (PDT). METHODS: From December 1992 through June 1999, 420 critically ill patients underwent 422 PDTs. There were 340 (81%) long-term survivors, 100 (29%) of whom were interviewed and offered further evaluation by fiberoptic laryngotracheoscopy (FOL) and tracheal computed tomography (CT). Tracheal stenosis was defined as more than 10% tracheal narrowing on transaxial sections or coronal and sagittal reconstruction views. Forty-eight patients agreed to CT evaluation; 38 patients also underwent FOL. CT and FOL evaluations occurred at 30 +/- 25 (mean +/- standard deviation) months after PDT. RESULTS: Twenty-seven (27%) patients reported voice changes and 2 (2%) reported persistent severe hoarseness. Vocal cord abnormalities occurred in 4/38 (11%) patients, laryngeal granuloma in 1 (3%) patient, focal tracheal mucosal erythema in 2 (5%) patients, and severe tracheomalacia/stenosis in 1 (2.6%) patient. CT identified mild (11-25%) stenosis in 10 (21%) asymptomatic patients, moderate (26-50%) stenosis in 4 (8.3%) patients, 2 who were symptomatic, and severe (>50%) stenosis in 1 (2%) symptomatic patient. Ten patients (10%) reported persistent respiratory problems after tracheal decannulation, but only four agreed to be studied. Two patients had moderate stenosis, and one had severe stenosis. One patient's CT scan was normal. No long-term stomal complications were identified or reported. CONCLUSIONS: Subjective voice changes and tracheal abnormalities are common after endotracheal intubation followed by PDT. Long-term follow-up of critically ill patients identified a 31% rate of more than 10% tracheal stenosis after PDT. Symptomatic stenosis manifested by subjective respiratory symptoms after decannulation was found in 3 of 48 (6%) patients.     

Suprastomal tracheal stenosis after dilational and surgical tracheostomy in critically ill patients

We have previously reported cases of severe suprastomal stenosis after tracheostomy. In this observational study we investigated the occurrence of suprastomal stenosis as a late complication. Patients with persistent tracheostomy after intensive care underwent an endoscopic examination of tracheostoma, larynx and trachea. A percutaneous dilational tracheostomy was employed in 105 (71.9%) and surgical tracheostomy in 41 (28.1%) of the cases (n = 146). The incidence of severe suprastomal stenosis (grade II > 50% of the lumen) was 23.8% (25 of 105) after dilational tracheostomy and 7.3% (3 of 41) after surgical tracheostomy (p = 0.033). Age, gender, underlying disease, ventilation time, and swallowing ability were not significantly associated with the tracheal pathology. This study suggests that dilational tracheostomy is associated with an increased risk of severe suprastomal tracheal stenosis compared to the surgical technique.     

Light-guided tracheal puncture for percutaneous tracheostomy

PURPOSE: To determine the effectiveness of lightwand-guided tracheal puncture for percutaneous tracheostomy. METHODS: The desired puncture site was marked on the skin of the anterior neck. A lightwand (Trachlight) was inserted into the patient's endotracheal tube (ETT), so that the number indicator on the lightwand matched the number indicator of the ETT of the patient. At this position, the light bulb of the lightwand was exactly placed at the tip of the endotracheal tube. With the lightwand turned on, the lightwand together with the endotracheal tube (ETT-LW) was slowly withdrawn from the trachea until a bright glow in the anterior neck could be seen 1 cm above the marked puncture site. At this position, the tip of the ETT was 1 cm above the puncture site. RESULTS: Percutaneous tracheostomy via a light-guided tracheal puncture was performed on 11 neurosurgical patients. The withdrawal of the endotracheal tube to a location above the puncture was accomplished easily with the lightwand. All percutaneous tracheostomies performed were successful, with ease and without any complications. The procedure time was 17.8 +/- 5.3 min. Mechanical ventilation was not interrupted during the whole procedure. CONCLUSION: The lightwand guided intratracheal puncture for percutaneous tracheostomy is a simple, effective, and safe procedure. This technique can avoid the risk of puncturing the endotracheal tube and/or cuff, thus allowing adequate ventilation and oxygenation during the percutaneous tracheostomy. Furthermore, this technique is inexpensive and minimizes the risk of damaging equipment like the fibreoptic bronchoscope.     

Evaluation of tracheal incisions for tracheostomy

Three standard tracheostomy incisions in dogs were compared to determine whether any were more likely associated with stomal stenosis. Each incision resulted in an average reduction in tracheal lumen of 25 per cent, with a 50 per cent maximum. The incision selected should depend on the conditions present.     

A cuff inflator for tracheal tubes

A simple automatic device* to inflate the tracheal tube cuff during emergency tracheal intubation is described. It was tested in 60 patients undergoing elective surgery and found to be a useful and efficient adjunct.     

A case of subglottic tracheal stenosis following tracheostomy successfully treated with laryngo-tracheal anastomosis]

A 77-year-old male patient underwent laryngo-tracheal anastomosis for subglottic tracheal stenosis. He developed exertional dyspnea 10 month after tracheostomy. Anterior and lateral wall of the cricoid cartilage and the first two tracheal cartilages were resected, preserving the recurrent laryngeal nerves. The distal trachea was anastomosed to the thyroid cartilage primarily and tracheostomy was made at 6th tracheal ring. Postoperatively, anterior flexion of the neck was maintained for a week. Oral intake was started on the 2nd postoperative day. The patient showed smooth recovery. The important points of this operation are: 1) preoperative evaluation of the residual subglottic space, 2) intraoperative care for preservation of the recurrent nerves, especially at the lateral sides of the crycoid cartilage, and 3) postoperative maintenance of the cervical anterior flexion.     

The airway management using laryngeal mask airway and tracheal fiberscopy in a pediatric patient with tracheal stenosis after tracheostomy

A 9-year-old boy was scheduled for excision of tracheal granuloma which had developed at the tip of a tracheostomy tube. Instead of a tracheostomy tube, a 4 mm ID tracheal tube was inserted via the tracheostomy beyond the tracheal constriction because of rapid development of respiratory failure. General anesthesia was induced and maintained with sevoflurane and oxygen via the tube, and a size 2.5 laryngeal mask airway (LMA) was inserted without muscle relaxant. Spontaneous respiration remained. Under monitoring by fiberoptic tracheoscopy via the LMA, the tracheal tube was extubated carefully. An 8 Fr. suction tube was indwelled via the tracheostomy beyond the stenosis for oxygen supply. After sealing the tracheostomy, he could breath spontaneously through the LMA. During the excision of tracheal granuloma by holmium:YAG laser, fiberoptic observation was continued via the LMA, and the procedure was performed without any complication. We conclude that the tracheal stenosis can be managed using the LMA, continuous fiberoptic monitoring and additional option of keeping spontaneous ventilation.     

Self-inflating parachute cuff. A new tracheostomy and endotracheal cuff

A new self-inflating cuff for endotracheal or tracheostomy tubes is described. It is self-inflating, never exerts a lateral wall pressure greater than tracheal pressure, is reliable at all ventilating pressures and flows, and maintains its reliability for extended periods of time when tested in vivo.